| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 10 |
| Brakes imbalanced across an axle | 5 |
| Windscreen washer not working | 4 |
| Registration plate lamp issues | 3 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Speed limiter plate shows a set speed greater than that permitted 125k speed limiter sticker fitted |6.5.A.2b| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Offside Front Outer Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings damage to chassis and excessive rot to that area |6.1.B.2| | 1 |
| Offside Rear Lower Brake pipe inappropriately repaired copper brake pipe repaired with plastic speed fit |3.6.A.3| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Speedometer cannot be illuminated |7.8 |c| |ii|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Nearside Upper Rear outline marker lamp|s| not working |1.1.B.1c| | 1 |
| Nearside Rear Upper Position lamp not working |4.2.1 |a|| | 1 |
| Braking system leaking Auxilary brake pedal leaking from inlet pipe |1.1.3 |d|| | 1 |
| Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced full of water and condensation |4.1.4 |b|| | 1 |
| Nearside Front Passenger grab handle insecure |9.6 |b| |ii|| | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Rear Upper Suspension bellows damaged or deteriorated and function is seriously affected (5.3.5 (b) (ii)) | 1 |
| Offside Rear Upper Anti-roll bar linkage insecurely attached (5.3.3 (a) (i)) | 1 |
| Offside Rear Air brake cylinder/actuator leaking (1.1.16 (b) (i)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Nearside Front Front outline marker lamp|s| not working N/S Front top marker light not working |1.1.B.1c| | 1 |
| Driver`s seat insecure drivers seat loose bolt need tightening up |6.2.A.1| | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Oil leaking excessively from transmission filter area (8.4.1 (a) (i)) | 1 |
| Passenger`s seat insecure passenger seat next to driver .seat back bolts loose |6.2.A.1| | 1 |
| Central Rear Emergency exit window cannot be opened from inside the vehicle stiff in operation (9.1.2 (a)) | 1 |
| Offside Front Fuel cap/sealing device missing (6.1.3 (b) (i)) | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Braking system leaking (1.1.3 (d)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Seat belt missing (7.1.2 (a)) | 1 |
| Offside Body component damaged and likely to cause injury sharp edge down the O/S in front the rear axle on the bottom panel (6.2.1 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Rear Brake slack adjuster incorrectly adjusted (1.1.18 (a)) | 1 |
| Nearside Rear Suspension bellows leaking Air leak (5.3.5 (c)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Offside Front Upper Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Brake drum back plate insecure (1.1.14 (d)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Offside All direction indicators not working No o/s indicators operating (4.4.1 (a) (ii)) | 1 |
| Offside Rear Emergency exit door cannot be opened from outside the vehicle Does not operate (9.1.2 (a)) | 1 |
| Offside Front Steering system fouling Drag link clamp in contact with lower part of airbag pedastel when steering operated (2.1.4 (a)) | 1 |
| Nearside Rear Upper Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Drag link end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |