| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 11 |
| Brake pipe excessively corroded | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Indicator switch faulty |1.4.A.1| | 2 |
| Registration plate lamp issues | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Brakes imbalanced across an axle | 2 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Brake load sensing valve linkage obviously incorrectly adjusted |3.6.E.3| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Windscreen washer control missing |8.2.1a| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Vehicle Identification Number not permanently displayed |6.3.5.a| | 1 |
| Battery insecure under drivers seat |1.9.1| | 1 |
| Registration plate issues | 1 |
| Brake load sensing valve has been removed and was fitted as standard |3.6.E.2| | 1 |
| Nearside Air suspension unit fouled by moving parts likely to cause damage steering arm |2.4.D.1c| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Windscreen wiper does not clear the windscreen effectively | 1 |
| Headlamp switch faulty main beam switch faulty allowing all lights to extinguish |1.7.1| | 1 |
| Rear fog lamp tell tale missing |1.3.1b| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner wing |6.1.B.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings front inner wing |6.1.B.2| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings front inner wing to rear off |6.1.B.2| | 1 |
| Nearside Front Leaf spring to axle securing nut insecure u bolts loose |2.4.B.7b| | 1 |
| Offside Front Leaf spring to axle securing nut insecure u bolts insecure |2.4.B.7b| | 1 |
| Nearside Front Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt link from steering box |2.2.C.1c| | 1 |
| Power steering pump drive system defective drive belt shreading |2.3.6| | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Obligatory mirror insecure |8.1.1| | 1 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Nearside Front Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Nearside Rear Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Headlamp switch faulty does not stay on main beam |1.7.1| | 1 |
| Main beam `tell-tale` not working not staying on correctly |1.7.4c| | 1 |
| Fuel tank leaking tank shows signs of leaking all around |7.2.3| | 1 |
| Rear Brake load sensing valve has been removed and was fitted as standard |3.6.E.2| | 1 |
| Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt steering arm from box |2.2.C.1c| | 1 |
| Rear brake binding | 1 |
| Brake load sensing valve has been disconnected and was fitted as standard |3.6.E.2| | 1 |
| Brake hose excessively deteriorated | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Offside Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Offside Front Anti-roll bar rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Air suspension unit deteriorated and likely to fail |2.4.D.1b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Air brake cylinder/actuator locking device insecure |3.6.H.2| | 1 |
| Speedometer not complete |6.7.2| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front front brake recording little or no effort |3.8.A.1a| | 1 |
| Indicator tell tale not working correctly |1.5.3| | 1 |
| Offside Windscreen wiper not operating automatically when switched on |6.1.1b| | 1 |
| Nearside Side repeater insecure |1.5.1a| | 1 |
| Offside Rear position lamp|s| not in good working order |not working| |1.1.4a| | 1 |
| Nearside Rear position lamp|s| not in good working order |not working| |1.1.4a| | 1 |
| Nearside Body has sharp edges or projections caused by corrosion or damage making the vehicle dangerous to other road users |6.5.10| | 1 |