Most common failures | No# failures |
---|
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 22 |
Parking brake: efficiency below requirements |3.7.B.7| | 22 |
Brake pipe excessively corroded | 21 |
Headlamp aim out of alignment | 19 |
Registration plate lamp issues | 15 |
Parking brake lever has no reserve travel |3.1.6b| | 8 |
Nearside Side repeater not working |1.4.A.2c| | 7 |
Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
Brake hose excessively deteriorated | 6 |
Windscreen wiper does not clear the windscreen effectively | 6 |
Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 5 |
Rear brake disc in such a condition that it is seriously weakened | 5 |
Rear parking brake recording little or no effort | 5 |
Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 4 |
Brakes imbalanced across an axle | 4 |
Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
Nearside Headlamp not working on main beam |1.7.5a| | 3 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 3 |
Rear brake binding | 3 |
Offside Rear wheel bearing has excessive play |2.6.2| | 3 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 3 |
Parking brake: efficiency below requirements (3.7.B.7) | 3 |
Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
Nearside Rear Exhaust system not adequately supported |7.1.1| | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
Offside Front Headlamp not working on main beam |1.7.5a| | 2 |
Front Sub-frame rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 2 |
All direction indicators not working (4.4.1 (a) (ii)) | 2 |
Hazard warning lamps inoperative (4.4.1 (e)) | 2 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
All position lamps not working |1.1.A.3b| | 2 |
Offside Headlamp not working on main beam |1.7.5a| | 2 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
Power steering malfunctioning |2.1.5 |a|| | 2 |
Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
Offside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
Front brake excessively fluctuating | 2 |
Offside Front Direction indicator not working |1.4.A.2c| | 2 |
Mechanical brake component has restricted free movement | 2 |
Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Direction indicators not working |1.4.A.2c| | 2 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 2 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Exhaust emissions carbon monoxide content excessive (7.3.B.1a) | 2 |
Horn not working |1.6.2a| | 2 |
Nearside Side repeater not working (4.4.1 (a) (ii)) | 2 |
Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 2 |
Emissions not tested (8.2.1.2 (d)) | 1 |
Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
Rear fog lamp has less than 50% of the light sources illuminating |1.3.2b| | 1 |
Bonnet retaining device ineffective |8.4.2| | 1 |
Power steering pump leaking from a failed component |2.3.3b| | 1 |
Nearside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
Front Horn not working (7.7 (a) (ii)) | 1 |
Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
Offside Front Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 1 |
Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Hazard warning lamps inoperative |1.4.B.1b| | 1 |
Indicator switch faulty |1.4.A.1| | 1 |
Offside Rear brake disc contaminated by oil |3.5.1h| | 1 |
Fluid leaking continuously posing a serious risk to road safety Petrol (8.4.1 (a) (ii)) | 1 |
Headlamp not working on main beam Both (4.1.1 (a) (ii)) | 1 |
Nearside Front Anti-roll bar attachment bracket/mounting likely to become detached (5.3.3 (a) (ii)) | 1 |
Nearside Front Anti-roll bar attachment bracket/mounting corroded and seriously weakened Chassis rail corroded around mounting (5.3.3 (b) (i)) | 1 |
Nearside Front Upper Suspension component ball joint dust cover missing (5.3.4 (b) (ii)) | 1 |
Rear Service brake effort inadequate at a wheel Both rear brake efforts drop to zero effort after 3 seconds of constant foot brake pressue (1.2.1 (a) (i)) | 1 |
Emissions not tested Due to fuel leak (8.2.1.2 (d)) | 1 |
Brake master cylinder/servo mounting prescribed area is excessively corroded (1.1.21 (e) (i)) | 1 |
Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Fuel system component leaking |7.2.3| | 1 |
Nearside front brake binding |3.7.B.1| | 1 |
Centre Stop lamp not working |1.2.1b| | 1 |
Centre Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Sub-frame attachment rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Sub-frame attachment rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Exhaust has a major leak of exhaust gases Silencer missing (6.1.2 (a)) | 1 |
Power steering malfunctioning |2.3.3a| | 1 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear fog lamp insecure |1.3.2a| | 1 |
Offside Rear fog lamp not working |1.3.2b| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Inner Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen |3.5 |a|| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Driver`s seat insecure |6.2.A.1| | 1 |
Nearside Front Lower Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Sub-frame rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Central Steering locking device ineffective |2.1.3 |d|| | 1 |
Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Nearside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Anti-roll bar linkage insecure bolt snapped |2.4.G.1| | 1 |
Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Lower Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Centre Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Registration plate issues | 1 |
Nearside Front Subframe mounting prescribed area is fractured |2.4.A.3| | 1 |
Nearside Front Sub-frame rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Suspension component mounting prescribed area is fractured |2.4.A.3| | 1 |
Offside Front Suspension component mounting prescribed area is fractured |2.4.A.3| | 1 |
Rear Sub-frame rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Seat belt anchorage prescribed area is fractured |5.2.6| | 1 |
Offside Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Nearside Stop lamp not working |1.2.1b| | 1 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Service brake: efficiency below requirements |3.7.D.4| | 1 |
Parking brake: efficiency below requirements |3.7.D.4| | 1 |
Offside Side repeater not working |1.4.A.2c| | 1 |
Offside Rear Lower Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Power steering inoperative and steering adversely affected |2.1.5 |c| |ii|| | 1 |
Power steering component leaking box |2.1.5 |a|| | 1 |
Steering linkage ball joint has excessive play on to drop arm |2.1.3 |b| |i|| | 1 |
Nearside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch |5.3.6 |a| |i|| | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength by jacking point |5.3.6 |a| |i|| | 1 |
Offside Rear Suspension arm pin or bush likely to become detached front bush |5.3.4 |a| |ii|| | 1 |
Nearside Rear Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
Rear fog lamp not working |1.3.2b| | 1 |
Rear fog lamp tell tale not working |1.3.1b| | 1 |
Steering system excessively rough |2.2.D.1| | 1 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
Offside Rear Seat belt anchorage prescribed area is inadequately repaired sill insufficient welding |5.2.6| | 1 |
Offside Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
Offside Rear Shock absorber has a serious fluid leak rear of 2 |2.7.3| | 1 |
Nearside Rear Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
Nearside Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
Offside Rear Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Centre Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
Front Exhaust mounting missing |7.1.1b| | 1 |
Hazard warning lamps inoperative |1.4.B.1b| | 1 |
Nearside Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Windscreen wiper not working (3.4 (a)) | 1 |
Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength under wing (5.3.6 (a) (i)) | 1 |
Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength under wing (5.3.6 (a) (i)) | 1 |
Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Front Drag link end ball joint has excessive play drop arm end |2.2.B.1f| | 1 |
Nearside Lower Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Front Sub-frame rubber bush deteriorated resulting in excessive movement both sides axsle mountings |2.4.G.2| | 1 |
Front Sub-frame attachment rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
An item not tested |Manual| | 1 |
Hazard warning switch insecure |1.4.B.1d| | 1 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Steering column universal joint has excessive play |2.1.5| | 1 |
Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Front suspension has excessive play in a pin or bush of an upper wishbone inner bearing |2.5.B.1a| | 1 |
Nearside Front Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Rear Body has a sharp edge caused by corrosion boot floor |6.1.C.1| | 1 |
Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Exhaust emissions hydrocarbon content excessive (7.3.B.1b) | 1 |
Nearside Front Upper Sub-frame pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Rear Suspension arm pin or bush excessively worn rear trailing arm bush (5.3.4 (a) (i)) | 1 |
Offside Inner Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt (2.2.C.1c) | 1 |
Nearside Rear Seat belt retracting mechanism defective (5.2.5b) | 1 |
Nearside Rear Sub-frame attachment bracket/mounting insecure (2.4.G.1) | 1 |
Nearside Front Brake pipe leaking (3.6.A.1) | 1 |
Brake performance not tested Brake fluid leak (3.7.A.1) | 1 |
Parking brake lever has no reserve travel (3.1.6b) | 1 |
Brake performance not tested (3.7.A.1) | 1 |
Braking system leaking (3.6.A.1) | 1 |
Offside Rear Sub-frame rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
front brake binding |3.7.B.1| | 1 |
Brake pipe leaking |3.6.A.1| | 1 |
Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Service brake: efficiency below requirements |3.7.B.7| | 1 |
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
Nearside Rear Lower Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
Offside Rear Lower Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
Position lamp switch does not illuminate the front and rear position lamps with a single operation (4.2.2 (a)) | 1 |
Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
Nearside Rear Seat belt anchorage loose (7.1.1 (b)) | 1 |
Nearside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
Parking brake lever has excessive movement indicating incorrect adjustment top of travel (1.1.6 (c)) | 1 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
Service brake lagging in operation brake pedal spungy (1.2.1 (d)) | 1 |
Front Hazard warning lamps inoperative |1.4.B.1b| | 1 |
Front Direction indicator not working |1.4.A.2c| | 1 |
Offside Front Power steering fluid level below minimum |2.3.1| | 1 |
Rear Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
Nearside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Nearside Side repeater not working |4.4.1 |a| |ii|| | 1 |
Exhaust carbon monoxide content at idle exceeds default limits |8.2.1.2 |b|| | 1 |