| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 10 |
| Windscreen wiper does not clear the windscreen effectively | 5 |
| Registration plate issues | 5 |
| Brake hose excessively deteriorated | 4 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Brake pipe excessively corroded | 2 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust emissions - engine idle speed too high (8.2.1.2 (e)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor area,marked in yellow (5.3.6 (a) (i)) | 1 |
| Offside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Main beam tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Front Headlamp aim projected beam image is obviously incorrect both sides no pattern (4.1.2 (c)) | 1 |
| Registration plate lamp issues | 1 |
| Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Hazard warning switch inoperative |4.4.2 |a| |ii|| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Offside Front Upper Suspension component pin or bush excessively worn shock absorber |5.3.4 |a| |i|| | 1 |
| Nearside Rear Statutory seat belt missing |5.1.1| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Offside Front Upper Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Power steering component|s| leaking fluid dripping out of both steering rack boots |2.3.3b| | 1 |
| Power steering inoperative |2.3.3a| | 1 |
| Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Rear Fuel pipe leaking |7.2.3| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside rear brake grabbing severely |3.7.A.5b| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive reading = 9.95 |7.3.D.3| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits reading 0.770 |7.3.D.3| | 1 |
| Offside Rear Anti-lock braking system wiring excessively damaged |3.4.3| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
| Offside Front coil spring corroded so that its cross sectional area is reduced and seriously weakened |2.4.C.1b| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Horn not working |1.6.2a| | 1 |