| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 14 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 14 |
| Headlamp aim out of alignment | 11 |
| Offside Rear fog lamp not working |1.3.2b| | 9 |
| Brakes imbalanced across an axle | 7 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 5 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 5 |
| Rear fog lamp not working |1.3.2b| | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Registration plate issues | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Rear brake application uneven | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Offside Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 2 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Seat belt anchorage prescribed area is excessively corroded Both outer sills and offside rear inner wheel arch |5.2.6| | 1 |
| Nearside Stop lamp excessively deteriorated so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Offside Stop lamp excessively deteriorated so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Headlamp not working on dipped beam both |1.7.5a| | 1 |
| Headlamp not working on main beam both |1.7.5a| | 1 |
| Front Outer Anti-roll bar linkage has excessive play in a pin/bush both sides |2.4.G.2| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded innersill end cover |5.2.6| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Brake pipe excessively corroded | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Track rod end loose |2.2.B.1d| | 1 |
| Nearside Outer Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Offside Rear Stop lamp adversely affected by the operation of another lamp stop light and side light wired incorrectly/bulb fitted incorrectly? |1.2.1f| | 1 |
| Centre Exhaust system not adequately supported other mountings splitting |7.1.1| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded large corrosion hole inner wheel arch |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded corrosion in rear of offside door sill |5.2.6| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded close to offside rear shock obsorber |2.4.A.3| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded door sill at center |5.2.6| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front coil spring incomplete |2.4.C.1a| | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Front Anti-roll bar synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front coil spring fractured |2.4.C.1a| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Windscreen has damage | 1 |
| Rear fog lamp insecure |1.3.2a| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Windscreen wiper blade missing |8.2.2| | 1 |
| Steering system excessively rough |2.2.D.1| | 1 |
| Offside Outer Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Panhard rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Panhard rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Registration plate lamp issues | 1 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside rear brake grabbing severely |3.7.A.5b| | 1 |
| Nearside Front Torsion bar excessive play at an end fixing |2.4.E.2| | 1 |
| Offside Front Torsion bar excessive play at an end fixing |2.4.E.2| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Bonded suspension unit attachment damaged and seriously weakened |2.4.F.1c| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Offside Rear fog lamp insecure |1.3.2a| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 1 |
| Nearside brake disc has restricted free movement |3.5.1j| | 1 |
| Offside brake disc has restricted free movement |3.5.1j| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Service brake application uneven across the axle |3.7.D.2b| | 1 |