| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 17 |
| Brake pipe excessively corroded | 13 |
| Rear brake binding | 11 |
| Service brake: efficiency below requirements |3.7.B.7| | 10 |
| Exhaust system not adequately supported |7.1.1| | 7 |
| Windscreen wiper does not clear the windscreen effectively | 7 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 6 |
| Brake hose excessively deteriorated | 6 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 5 |
| Registration plate lamp issues | 5 |
| Offside Rear fog lamp not working |1.3.2b| | 5 |
| Rear brake application uneven | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Brakes imbalanced across an axle | 4 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Horn not working |1.6.2a| | 3 |
| Battery insecure |1.9.1| | 3 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Headlamp not working on main beam |1.7.5a| | 3 |
| Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Headlamp not working on main beam |1.7.5a| | 3 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 3 |
| Brake load sensing valve linkage seized |3.6.E.3| | 3 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 2 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Offside Headlamp insecure |1.7.3| | 2 |
| Offside Rear fog lamp missing |1.3.2a| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 2 |
| Nearside Headlamp insecure |4.1.1 |c|| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Headlamp insecure |1.7.3| | 2 |
| Brake load sensing valve seized |3.6.E.3| | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp aim not tested (4.1.2 (b)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Power steering ram leaking (2.1.5 (a)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Spare wheel insecure |6.4.2| | 1 |
| Centre Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Offside Parking brake recording little or no effort |3.7.D.3a| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Headlamp insecure |1.7.3| | 1 |
| Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Front Exhaust has a major leak of exhaust gases pipe broke off |7.1.2| | 1 |
| Front Exhaust system not adequately supported pipe broke off |7.1.1| | 1 |
| Offside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded valence |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded inner and outer valence |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded inner wing |2.4.A.3| | 1 |
| Centre Front Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Outer Front constant velocity joint is insecure |2.5.C.1b| | 1 |
| Nearside Rear Shock absorber insecure |2.7.2b| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front Upper Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Trailer electrical socket |13 pin| not operating the trailer lamps as intended |1.9.4| | 1 |
| Nearside Front Front constant velocity joint is insecure |2.5.C.1b| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Front brake application uneven | 1 |
| Nearside Rear Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
| Offside Rear Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
| Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Headlamp light intensity severely reduced and too low (4.1.4 (a)) | 1 |
| Nearside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Brake load sensing valve inoperative |3.6.E.3| | 1 |
| Rear Brake load sensing valve linkage obviously incorrectly adjusted |3.6.E.3| | 1 |
| Nearside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Exhaust has a major leak of exhaust gases tailpipe deteriorated |6.1.2 |a|| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Side repeater missing |1.4.A.2b| | 1 |
| Offside Side repeater missing |1.4.A.2b| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Battery insecure leisure |1.9.1| | 1 |
| Exhaust has a major leak of exhaust gases tail pipe |7.1.2| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Offside Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
| Fuel system component leaking At fuel pump(engine). (6.1.3 (b) (i)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Exhaust system insecure Numerous hanger mountings missing & system fouling parking brake cables. (6.1.2 (a)) | 1 |
| Headlamp not working on dipped beam At nearside & offside front. (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp lens missing (4.1.1 (b) (ii)) | 1 |
| Main beam tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Nearside Front Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |