| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 23 |
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Registration plate lamp issues | 9 |
| Brakes imbalanced across an axle | 6 |
| Nearside Side repeater not working |1.4.A.2c| | 6 |
| Offside Side repeater not working |1.4.A.2c| | 6 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Front brake disc in such a condition that it is seriously weakened | 5 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Brake pipe excessively corroded | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 3 |
| Nearside Front coil spring fractured |2.4.C.1a| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Brake load sensing valve linkage seized |3.6.E.3| | 3 |
| Offside Headlamp insecure |1.7.3| | 3 |
| Front brake application uneven | 3 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 2 |
| Brake has no servo assistance |3.3.B.2| | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Offside Front Direction indicator not working |1.4.A.2c| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Front brake disc excessively pitted |3.5.1h| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Stop lamp not working |1.2.1b| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Side repeater not working |1.4.A.2c| | 2 |
| Nearside Front Headlamp insecure |1.7.3| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Nearside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 2 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Nearside Front Direction indicator insecure |1.4.A.2b| | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Direction indicator incomplete |1.5.A1b| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
| Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Exhaust emissions test not completed because smoke levels are significantly in excess of the specified limit values (8.2.2.2 (f)) | 1 |
| Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Position lamp switch missing |1.1.A.1| | 1 |
| Front Anti-roll bar rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Registration plate issues | 1 |
| Nearside Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
| Steering wheel locking device insecure |2.1.6| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front position lamp|s| insecure |1.1.A.3a| | 1 |
| Offside Rear position lamp|s| insecure |1.1.A.3a| | 1 |
| Offside Rear Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Side repeater missing |1.4.A.2b| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Nearside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Offside Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Rear Direction indicator incomplete |1.5.A1b| | 1 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Offside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Outer Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Side repeater insecure |1.4.A.2b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Rear Coil spring missing (5.3.1 (c) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative |1.1.17 |c| |ii|| | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Brake pedal pad not secure to the pedal |3.3.A.1c| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Exhaust engine idle speed too high |7.3.A.2a| | 1 |
| Nearside Headlamp aim headlamp not in good working order adversely affecting beam image |1.2.4b| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Brake servo inoperative (1.1.10 (a) (ii)) | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Windscreen washer not working | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill panel (5.3.6 (a) (i)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside brake disc contaminated by grease |3.5.1h| | 1 |
| Offside Front brake caliper securing device missing |3.5.1j| | 1 |