Most common failures | No# failures |
---|
Headlamp aim out of alignment | 20 |
Brake pipe excessively corroded | 18 |
Service brake: efficiency below requirements |3.7.B.7| | 10 |
Brakes imbalanced across an axle | 7 |
Rear brake binding | 5 |
Exhaust system not adequately supported |7.1.1| | 5 |
Windscreen wiper does not clear the windscreen effectively | 5 |
Brake hose excessively deteriorated | 5 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 3 |
Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
Nearside Stop lamp not working |1.2.1b| | 3 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
Parking brake: efficiency below requirements |3.7.B.7| | 2 |
Offside Headlamp not working on main beam |1.7.5a| | 2 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 2 |
Windscreen washer not working | 2 |
Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
Offside Seat belt anchorage prescribed area strength or continuity significantly reduced Inner and outer sill |7.1.1 |a| |i|| | 1 |
Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced Inner sill |7.1.1 |a| |i|| | 1 |
Offside Body panel corroded and likely to cause injury Wheel arch |6.2.1 |a| |i|| | 1 |
Exhaust emissions likely to be affected by an exhaust leak |8.2.2.1 |b|| | 1 |
Offside Parking |secondary brake| on a single line braking system has no recorded effort at a wheel |1.3.1 |a| |ii|| | 1 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
Headlamp aim so that beam "kick up" is not visible on the screen Kick up going wrong way |4.1.2 |a|| | 1 |
Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Battery insecure and likely to cause a short circuit |4.13 |a| |ii|| | 1 |
Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
Nearside Rear Upper Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting spring anger mounting |6.2.2 |d| |i|| | 1 |
Nearside Outer Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Exhaust system insecure (6.1.2 (a)) | 1 |
Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Front Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
Registration plate lamp issues | 1 |
Nearside Front Headlamp insecure |1.7.3| | 1 |
Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
Front brake disc in such a condition that it is seriously weakened | 1 |
Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Offside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
Offside Rear Wheel bearing rough when rotated unable to check (5.1.3 (b) (i)) | 1 |
Offside Headlamp aim not tested |1.8.A.1c| | 1 |
Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Offside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
Nearside Rear brake drum contaminated by brake fluid |3.5.1h| | 1 |
Offside Front Seat belt flexible stalk damaged likely to lead to failure under load |5.2.4a| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Horn not working (7.7 (a)) | 1 |
Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Offside Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Nearside Front Headlamp insecure |4.1.1 |c|| | 1 |
Offside Front Headlamp insecure |4.1.1 |c|| | 1 |
Nearside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
Offside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
Nearside Front Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
Offside Front Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
Offside Front Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
Battery insecure |1.9.1| | 1 |
Exhaust mounting missing |7.1.1b| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Nearside Rear Lower Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Rear Brake load sensing valve linkage defective and function impaired (1.1.17 (a)) | 1 |
Nearside Rear Brake valve leaking load sensing valve leaking (1.1.7 (d) (i)) | 1 |
Central Front Exhaust has a major leak of exhaust gases front pipe (6.1.2 (a)) | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength n/s/r front spring hanger (5.3.6 (a) (i)) | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength spring hanger. (5.3.6 (a) (i)) | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength o/s/r rear of spring chassis corroded (5.3.6 (a) (i)) | 1 |
Emissions not tested exhaust leak (8.2.2.2 (e)) | 1 |
Brake performance not tested not tested due to leak (1.2.1 (g)) | 1 |
Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Offside Headlamp insecure (4.1.1 (c)) | 1 |
Offside Front Passenger`s seat insecure |6.2.A.1| | 1 |
Offside Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Brake load sensing valve linkage seized |3.6.E.3| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength forward (5.3.6 (a) (i)) | 1 |
Nearside Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Offside Exhaust system insecure |6.1.2 |a|| | 1 |
Nearside Rear Brake pipe likely to become detached or damaged |1.1.11 |d| |ii|| | 1 |
Offside Rear Leaf spring anchor bracket corroded and seriously weakened (5.3.1 (b) (i)) | 1 |
Nearside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength above rear spring hanger mounting bracket (5.3.6 (a) (i)) | 1 |