| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 53 |
| Headlamp aim out of alignment | 32 |
| Windscreen wiper does not clear the windscreen effectively | 30 |
| Offside Stop lamp not working |1.2.1b| | 16 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 14 |
| Nearside Stop lamp not working |1.2.1b| | 14 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 13 |
| Brakes imbalanced across an axle | 12 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 11 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 10 |
| Horn not working |1.6.2a| | 9 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 9 |
| Rear Exhaust system not adequately supported |7.1.1| | 7 |
| Battery insecure |1.9.1| | 7 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 6 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 5 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 5 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 4 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 4 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Nearside Rear Stop lamp not working |1.2.1b| | 4 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 4 |
| Exhaust system not adequately supported |7.1.1| | 4 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 4 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 4 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Rear brake application uneven | 3 |
| Rear parking brake recording little or no effort | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Front brake disc in such a condition that it is seriously weakened | 3 |
| Registration plate issues | 3 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 3 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
| Emissions not tested |7.0| | 3 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 3 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 2 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Power steering component|s| leaking |2.3.3b| | 2 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Windscreen has damage | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Brake load sensing valve seized |3.6.E.3| | 2 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 2 |
| Nearside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 2 |
| Centre Stop lamp not working |1.2.1b| | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Front Upper Macpherson strut top bush or bearing has excessive wear or free play (5.3.4 (a) (i)) | 2 |
| Lower Engine mounting damaged or deteriorated resulting in excessive movement (6.1.8 (a) (i)) | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 2 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Horn not working (7.7 (a)) | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced Outer sill (7.1.1 (a) (i)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced Outer sill (7.1.1 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Front position lamp|s| not working side lights |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| not working side lights |1.1.A.3b| | 1 |
| Nearside Front Drive shaft which forms part of the suspension coupling gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Nearside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement rear bush |2.4.G.2| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Inner Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Inner Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Front Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn ARM REAR BUSH |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn ARM REAR BUSH |5.3.4 |a| |i|| | 1 |
| Vehicle structure is deformed and structural rigidity is significantly reduced nearside outer sill (6.1.1 (a) (i)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Emissions not tested water leak (8.2.1.2 (d)) | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Offside Front Lower Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Nearside Rear Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Offside Front constant velocity joint is excessively worn |2.5.C.1b| | 1 |
| Rear Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Windscreen washer not working | 1 |
| Emissions not tested due too engine warning lamp ,over heating (8.2.1.2 (d)) | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front suspension has a suspension lower ball joint securing nut loose |2.5.B.1a| | 1 |
| Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Nearside Front Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Obligatory mirror insecure |8.1.1| | 1 |
| Brake performance not tested air in system (1.2.1 (g)) | 1 |
| Front Windscreen damaged and affecting the drivers view of the road (3.2 (a) (ii)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Nearside Rear Hydraulic fluid leaking excessively (8.4.1 (a) (i)) | 1 |
| Offside Front Lower Steering linkage ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Driver`s view of the road through the swept area of the windscreen materially affected by an obstruction |3.1 |a| |ii|| | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Exhaust has a major leak of exhaust gases middle exhaust box (6.1.2 (a)) | 1 |
| Offside Front Outer Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Outer Stop lamp not working |1.2.1b| | 1 |
| Offside Outer Stop lamp not working |1.2.1b| | 1 |
| Power steering inoperative |2.1.5 |c| |i|| | 1 |
| Nearside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Nearside Headlamp aim beam image obviously incorrect bulb pattern |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect bulb pattern |1.8.A.1b| | 1 |
| Nearside Position lamp showing white light to the rear |4.2.3 |a| |ii|| | 1 |
| Power steering inoperative and steering adversely affected (2.1.5 (c) (ii)) | 1 |
| Power steering fluid reservoir empty (2.1.5 (b) (ii)) | 1 |
| Power steering pump fractured and steering adversely affected (2.1.5 (d) (ii)) | 1 |
| Power steering pump leaking (2.1.5 (a)) | 1 |
| Front Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Front Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Offside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear Suspension arm has excessive play in a pin/bush p-bush |2.4.G.2| | 1 |
| Offside Rear Suspension arm has excessive play in a pin/bush p-bush |2.4.G.2| | 1 |
| Offside Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases back box |7.1.2| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front Lower Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Rear Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Upper Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Front Drag link end ball joint has excessive play inner rack ends (2.1.3 (b) (i)) | 1 |
| Offside Front Drag link end ball joint has excessive play inner rack ends (2.1.3 (b) (i)) | 1 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Rear position lamp|s| not working n/s |1.1.A.3b| | 1 |
| Rear position lamp|s| not working o/s |1.1.A.3b| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Brake load sensing valve seized but ABS functioning (1.1.17 (c) (i)) | 1 |
| Nearside Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Brake load sensing valve seized but ABS functioning |1.1.17 |c| |i|| | 1 |
| Nearside Front Lower Steering linkage ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Rear Exhaust silencer insecure (8.1.1 (b) (i)) | 1 |
| Emissions not tested exhaust blow (8.2.1.2 (d)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Power steering inoperative |2.3.3a| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Lower Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Front Ball joint has excessive play track rod |2.2.B.1f| | 1 |
| brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear Axle beam has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Brake load sensing valve inoperative |3.6.E.3| | 1 |
| Offside Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Steering rack has excessive free play detected at the steering wheel (steering rack fitted) UJ joint above steering rack (2.3 (a) (i)) | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Air brake cylinder/actuator leaking limiter valve |1.1.16 |b| |i|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill |5.3.6 |a| |i|| | 1 |
| Brake pipe excessively corroded | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Nearside Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement front bush |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement front bush |2.4.G.2| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Radius arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |