| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 52 |
| Headlamp aim out of alignment | 28 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 27 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 22 |
| Offside Rear fog lamp not working |1.3.2b| | 18 |
| Rear fog lamp tell tale not working |1.3.1b| | 18 |
| Rear fog lamp not working |1.3.2b| | 16 |
| Front brake disc in such a condition that it is seriously weakened | 10 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 9 |
| Anti-lock braking system warning lamp indicates an ABS fault | 9 |
| Centre Stop lamp not working |1.2.1b| | 9 |
| Brakes imbalanced across an axle | 9 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 8 |
| Rear Exhaust system not adequately supported |7.1.1| | 7 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 7 |
| Rear parking brake recording little or no effort | 6 |
| Battery insecure |1.9.1| | 6 |
| Parking brake lever has no reserve travel |3.1.6b| | 6 |
| Nearside Stop lamp not working |1.2.1b| | 6 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 6 |
| Offside Front Anti-roll bar linkage fractured |2.4.G.1| | 5 |
| Offside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Nearside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 4 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
| Nearside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 4 |
| Offside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 4 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Offside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Front Anti-roll bar linkage missing |2.4.G.1| | 3 |
| Offside Front Anti-roll bar linkage missing |2.4.G.1| | 3 |
| Power steering component|s| leaking |2.3.3b| | 3 |
| Exhaust system not adequately supported |7.1.1| | 3 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 3 |
| Nearside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Brake hose excessively deteriorated | 3 |
| Offside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 2 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Front brake excessively fluctuating | 2 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Registration plate issues | 2 |
| Offside Front Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Centre Rear Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Driver`s seat insecure |6.2.A.1| | 2 |
| Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Windscreen has damage | 1 |
| Offside front brake juddering severely |3.7.A.2b| | 1 |
| Offside Front Anti-roll bar linkage cracked |2.4.G.1| | 1 |
| Offside Front Suspension arm locating pin locking device not properly locked |2.4.G.3b| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Centre Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Side repeater not working |1.4.A.2c| | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Brake hose has insufficient room to move | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Central Exhaust system not adequately supported mounting snapped. |7.1.1| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush Front bush |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement rear bush |2.4.G.2| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded outer sill. |2.4.A.3| | 1 |
| Rear brake binding | 1 |
| Nearside Front Lower Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 1 |
| Offside Front Lower Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 1 |
| Nearside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Offside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Nearside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Nearside Outer Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Offside Outer Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Offside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Headlamp lens seriously defective |4.1.1 |b| |ii|| | 1 |
| Nearside Headlamp light intensity severely reduced |4.1.4 |a|| | 1 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside front brake juddering severely |3.7.A.2b| | 1 |
| Nearside Front suspension has excessive play in a pin or bush of a lower wishbone inner bearing |2.5.B.1a| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Inner Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Upper engine mounting deteriorated resulting in excessive movement |6.1.D.1a| | 1 |
| Lower engine mounting deteriorated resulting in excessive movement |6.1.D.1a| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Offside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front Suspension arm rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Front brake application uneven | 1 |
| Nearside Front Suspension arm pin or bush likely to become detached Rear bush displaced. (5.3.4 (a) (ii)) | 1 |
| Offside Front Suspension arm pin or bush likely to become detached Rear bush displaced. (5.3.4 (a) (ii)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Nearside Front Anti-roll bar linkage insecurely attached (5.3.3 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Anti-lock braking system warning lamp does not illuminate |1.6 |a|| | 1 |
| Offside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill |7.1.1 |a| |i|| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Rear Upper Stop lamp not working |1.2.1b| | 1 |
| Nearside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Seat belt anchorage prescribed area strength or continuity significantly reduced o/s outer sill within 30cm of seat / seat belt anchorage points (7.1.1 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Offside Inner Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Headlamp incorrect colour |1.7.5b| | 1 |
| Nearside Front Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 1 |
| Nearside Rear brake caliper leaking |3.6.A.1| | 1 |
| Supplementary Restraint System warning lamp indicates a fault air bag light on |5.4.2| | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Offside Front Service brake excessively fluctuating 50 kgf (1.2.1 (e)) | 1 |
| Rear fog lamp switch missing (4.5.3 (a) (ii)) | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Rear fog lamp tell tale missing |1.3.1b| | 1 |
| Anti-lock braking system warning lamp sequence is incorrect |3.4.1d| | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Exhaust system insecure Rear (6.1.2 (a)) | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Rear Rear fog lamp switch missing (4.5.3 (a)) | 1 |
| Registration plate lamp issues | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Inner and outer body sill seriously corroded and holed. (5.3.6 (a) (i)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced Outer body sill seriously corroded and holed within 30cm of nearside front seatbelt mounting point. (7.1.1 (a) (i)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Anti-roll bar linkage missing |5.3.3 |a| |ii|| | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage missing (5.3.3 (a) (ii)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Nearside Front Anti-roll bar linkage insecure broken |2.4.G.1| | 1 |
| Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Outer Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear brake disc excessively scored |3.5.1h| | 1 |
| Offside Rear brake disc excessively scored |3.5.1h| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Anti-roll bar linkage missing |2.4.G.1| | 1 |
| Offside Anti-roll bar linkage missing |2.4.G.1| | 1 |
| Nearside Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Rear Exhaust system insecure MOUNT BROKEN (6.1.2 (a)) | 1 |
| Front Suspension arm rubber bush deteriorated resulting in excessive movement Both rear bushes |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Oil leaking excessively from transmission dripping |8.4.1 |a| |i|| | 1 |
| Rear Exhaust system insecure |6.1.2 |a|| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Lower Bonded suspension unit deteriorated and cannot function as intended |2.4.F.3| | 1 |
| Offside Front Lower Bonded suspension unit deteriorated and cannot function as intended |2.4.F.3| | 1 |
| Front Anti-roll bar linkage insecure broken |2.4.G.1| | 1 |
| Windscreen damaged and affecting the driver`s view of the road |3.2 |a| |ii|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Centre Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Nearside Front Lower Suspension arm synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Brake hydraulic reservoir cap missing |3.6.G.1a| | 1 |
| Nearside Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings SILL |6.1.B.2| | 1 |
| Offside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front brake caliper inappropriately repaired |3.5.1n| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Front Anti-roll bar has excessive play in a pin/bush both front bushes |2.4.G.2| | 1 |
| Rear Exhaust system not adequately supported bracket broken off |7.1.1| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Exhaust system not adequately supported middle hanger broken off |7.1.1| | 1 |
| Nearside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement rear bush |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement rear bush |2.4.G.2| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill |5.3.6 |a| |i|| | 1 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Oil leaking excessively from transmission |8.4.1 |a| |i|| | 1 |
| Power steering ram leaking steering rack leaking from both sides |2.1.5 |a|| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn wishbone rear bush |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn wishbone rear bush |5.3.4 |a| |i|| | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Centre Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Centre Front engine mounting deteriorated resulting in excessive movement |6.1.D.1a| | 1 |
| Rear Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Rear Road wheel cracked |4.2.A.1a| | 1 |
| Nearside Front Bonded suspension unit attachment damaged and seriously weakened |2.4.F.1c| | 1 |
| Offside Front Body panel corroded and likely to cause injury (6.2.1 (a) (i)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Subframe mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected (5.3.6 (a) (ii)) | 1 |
| Offside Front Subframe mounting prescribed area damaged to the extent that control of the vehicle is likely to be adversely affected (5.3.6 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting missing Drop link missing (5.3.3 (a) (ii)) | 1 |
| Outer Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Sills corroded (6.1.1 (c) (i)) | 1 |
| Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Sills corroded (6.1.1 (c) (i)) | 1 |
| Exhaust system not adequately supported rear mount adrift |7.1.1| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |