| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Headlamp aim out of alignment | 7 |
| Brake pipe excessively corroded | 5 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Registration plate lamp issues | 4 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 4 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Nearside Rear Stop lamp not working |1.2.1b| | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Emissions not tested |7.0| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Horn not working |1.6.2a| | 2 |
| Offside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Brakes imbalanced across an axle | 2 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Front Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Offside Front Anti-lock braking system wiring excessively damaged |3.4.3| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Rear position lamp|s| not working both |1.1.A.3b| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear fog lamp tell tale missing |1.3.1b| | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| front brake binding |3.7.B.1| | 1 |
| Nearside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Rear Tie bar/rod locating pin retaining device not properly locked |2.4.G.3b| | 1 |
| Horn control missing |1.6.1| | 1 |
| Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
| Offside Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear brake application uneven | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |