| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 12 |
| Headlamp aim out of alignment | 9 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Rear brake binding | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Registration plate issues | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 2 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| rear parking |secondary| brakes imbalanced | 2 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Brake lever has insufficient reserve travel Handbrake (1.1.2 (a)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Headlamp aim projected beam image is obviously incorrect Both sides UV Damage (4.1.2 (c)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Front Anti-roll bar pin or bush excessively worn Both sides D Bush (5.3.4 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases Central Section (6.1.2 (a)) | 1 |
| Nearside Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Steering rack gaiter missing or no longer prevents the ingress of dirt both sides small end insecure |2.1.3 |g| |ii|| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Offside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Rear Parking brake inoperative on one side N/S and O/S (1.4.1 (a)) | 1 |
| Nearside Rear Position lamp showing white light to the rear (4.2.3 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Brake pipe excessively corroded | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced Outer sill (7.1.1 (a) (i)) | 1 |
| Offside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Front Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Nearside Front Brake pipe inadequately supported pipe to hose mounting bracket insecure and fouling driveshaft |3.6.B.1| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement rear bush |2.4.G.2| | 1 |
| Battery insecure |1.9.1| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Upper Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Rear Direction indicator incorrect colour both |1.4.A.2f| | 1 |
| Offside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc holed |2.5.C.1a| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Brake hydraulic reservoir cap missing |1.1.10 |e|| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Front Inner Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front Inner Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Rear Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Anti-roll bar linkage worn and seriously weakened |2.4.G.1| | 1 |
| Offside Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Inner Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Inner Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Brake hose damaged | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front constant velocity joint is excessively worn |2.5.C.1b| | 1 |
| Offside Front constant velocity joint is excessively worn |2.5.C.1b| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |