| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 22 |
| Registration plate lamp issues | 19 |
| Headlamp aim out of alignment | 17 |
| Registration plate issues | 9 |
| Brakes imbalanced across an axle | 7 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 5 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 4 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Brake hose excessively deteriorated | 3 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Battery insecure |1.9.1| | 2 |
| Rear brake application uneven | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 2 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Front Upper Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Side repeater lens defective such that the emitted light is adversely affected |4.4.1 |b| |ii|| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Outer Drive shaft joint excessively worn (6.1.7 (c) (i)) | 1 |
| Front Headlamp not working on main beam |1.7.5a| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside rear parking |secondary| brake grabbing severely |3.7.B.6b| | 1 |
| Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Nearside Side repeater flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Offside Side repeater flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Offside Side repeater excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Side repeater excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Side repeater obscured more than 50% |1.4.A.2d| | 1 |
| Offside Side repeater obscured more than 50% |1.4.A.2d| | 1 |
| Lower Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Front Steering damper leaking oil |2.2.C.1f| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage insecurely attached (5.3.3 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength body mounting (5.3.6 (a) (i)) | 1 |
| Offside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Central Stop lamp not working |1.2.1b| | 1 |
| Rear Electrical wiring damaged, likely to cause a short |1.9.2b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Offside Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Rear parking brake recording little or no effort | 1 |
| Headlamps matched pair are not the same colour |1.7.6| | 1 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn droplink (5.3.4 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn droplink (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn droplink (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn D Bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Lower Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Nearside Front Headlamp insecure |4.1.1 |c|| | 1 |
| Offside Front Anti-roll bar linkage insecure and impairing directional stability |5.3.3 |a| |ii|| | 1 |
| Offside Front Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Anti-roll bar linkage insecure and impairing directional stability (5.3.3 (a) (ii)) | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Offside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement d bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement d bush |2.4.G.2| | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Offside Front Anti-roll bar locating pin insecure |2.4.G.3a| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Rear coil spring broken |2.4.C.1a| | 1 |
| Nearside Front Anti-roll bar linkage insecure and impairing directional stability drop link (5.3.3 (a) (ii)) | 1 |
| Offside Front Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
| Nearside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor pan within the body mounting. (5.3.6 (a) (i)) | 1 |
| Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Floor pan within the body mounting. (5.3.6 (a) (i)) | 1 |
| Brake pipe excessively corroded | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Axle swivel pins and bushes swivel pin and/or bush excessively worn joint worn. (5.1.2 (b) (i)) | 1 |
| Nearside Front Anti-roll bar linkage fractured (5.3.3 (b) (ii)) | 1 |
| Engine MIL inoperative or indicates a malfunction light on (8.2.1.2 (h)) | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Nearside Track rod end ball joint worn to the extent there is a serious risk of detachment |2.1.3 |b| |ii|| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front drive shaft coupling is excessively worn |2.5.C.1c| | 1 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Rear Passengers seat insecure (6.2.6 (a) (ii)) | 1 |
| Offside Front Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Front brake disc excessively scored |3.5.1h| | 1 |
| Offside Front brake disc excessively scored |3.5.1h| | 1 |
| Brake master cylinder fluid level below minimum level |3.6.G.1e| | 1 |
| Nearside Rear Lower Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Lower Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Front brake disc excessively scored |3.5.1h| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Nearside Front Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Front Lower Steering column universal joint insecure (2.1.3 (a) (i)) | 1 |
| Offside Front Brake hose excessively twisted (1.1.12 (b) (ii)) | 1 |
| Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Fuel hose leaking (6.1.3 (b) (i)) | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Drive shaft joint excessively worn (6.1.7 (c) (i)) | 1 |
| Front Prop shaft joint excessively worn front joint (6.1.7 (c) (i)) | 1 |
| Rear Seat belt missing buckles not accessible (7.1.2 (a)) | 1 |
| Central Rear Drive shaft joint so worn it is likely to fail (6.1.7 (c) (ii)) | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Offside Front Outer Drive shaft joint so worn it is likely to fail (6.1.7 (c) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage insecurely attached (5.3.3 (a) (i)) | 1 |
| Front front brake juddering severely |3.7.A.2b| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Service brake juddering severely |3.7.C.2| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Nearside Front Anti-roll bar linkage pin or bush likely to become detached lower bolt loose (5.3.4 (a) (ii)) | 1 |
| Offside Front Anti-roll bar linkage pin or bush likely to become detached lower bolt loose (5.3.4 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases rear pipe holed and blowing (6.1.2 (a)) | 1 |
| Exhaust system insecure rear tail pipe mounting broken off and pipe loose in to exhaust box (6.1.2 (a)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Rear Service brake grabbing severely (1.2.1 (c)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Front Upper Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage pin or bush likely to become detached (5.3.4 (a) (ii)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside Headlamp insecure (4.1.1 (c)) | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Front brake application uneven | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Front Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |