| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 30 |
| Windscreen wiper does not clear the windscreen effectively | 24 |
| Brake pipe excessively corroded | 24 |
| Registration plate lamp issues | 11 |
| Registration plate issues | 8 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 6 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 5 |
| Brakes imbalanced across an axle | 5 |
| Front brake disc in such a condition that it is seriously weakened | 5 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Rear fog lamp not working |1.3.2b| | 4 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 4 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 4 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 4 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 4 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 4 |
| Centre Stop lamp not working |1.2.1b| | 4 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 3 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
| Offside Front Anti-roll bar linkage fractured |2.4.G.1| | 3 |
| Offside Front Direction indicator not working |1.4.A.2c| | 3 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 3 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Windscreen has damage | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Steering damper leaking oil |2.2.C.1f| | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear Braking system leaking |3.6.A.1| | 2 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 2 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Headlamp missing |1.7.3| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Nearside rear parking |secondary| brake grabbing severely |3.7.B.6b| | 2 |
| Offside rear parking |secondary| brake grabbing severely |3.7.B.6b| | 2 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Front Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Rear Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Steering box has a significant oil leak |2.2.D.2e| | 2 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Lower Suspension arm attachment bracket/mounting cracked |2.4.G.1| | 1 |
| Position lamp switch does not illuminate the front and rear position lamps with a single operation |1.1.A.2| | 1 |
| Offside Front Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Rear Drive shaft uj which forms part of the suspension has excessive play in a universal joint prop shaft to rear axle universal joint |2.4.G.4b| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Rear Anti-roll bar rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Drag link end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Front Lower Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Bonnet retaining device ineffective |8.4.2| | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis behind wheel (5.3.6 (a) (i)) | 1 |
| Offside Front Prop shaft joint so worn it is likely to fail |6.1.7 |c| |ii|| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength trailing arm front bush mounting point (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength trailing arm front bush mounting point (5.3.6 (a) (i)) | 1 |
| Brake hose excessively deteriorated | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded chassis |2.4.A.3| | 1 |
| Rear Exhaust system not adequately supported hanger broken |7.1.1| | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Upper Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced steering box prescribed area (6.1.1 (c) (i)) | 1 |
| Nearside Front Lower Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength shock mounting prescribed area (5.3.6 (a) (i)) | 1 |
| Nearside Front Outer Drive shaft joint excessively worn (6.1.7 (c) (i)) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis, bottom arm front mounting prescribed area (5.3.6 (a) (i)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced chassis leg (6.1.1 (c) (i)) | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced chassis leg (6.1.1 (c) (i)) | 1 |
| Nearside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis, bottom arm mounting prescribed area (5.3.6 (a) (i)) | 1 |
| Nearside Front Upper Body panel corroded and likely to cause injury wing corroded(holed), front bonnet secure point (6.2.1 (a) (i)) | 1 |
| Offside Front Upper Body panel corroded and likely to cause injury wing corroded(holed), front bonnet secure point (6.2.1 (a) (i)) | 1 |
| Brake servo vacuum pipe deteriorated |3.6.C.1b| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced chassis (6.1.1 (c) (i)) | 1 |
| Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced chassis (6.1.1 (c) (i)) | 1 |
| Nearside Rear Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Offside Rear Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Nearside Front Anti-roll bar linkage insecurely attached (5.3.3 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage insecurely attached (5.3.3 (a) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| All position lamps adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Rear Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Hazard warning switch inoperative Lamps inoperative when engine is running and when the ignition switched off (4.4.2 (a) (ii)) | 1 |
| Nearside Front Seat belt not functioning as intended |7.1.2 |c|| | 1 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear Braking system leaking brake component |3.6.A.1| | 1 |
| Rear brake application uneven | 1 |
| Offside Rear Brake pipe fouled by moving parts Brake pipe routed through coil spring compression area |3.6.B.2a| | 1 |
| Nearside Front Steering system fouling wheel |2.2.D.2a| | 1 |
| Offside Front Steering system fouling |2.2.D.2a| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Side repeater incorrect colour |4.4.3 |a|| | 1 |
| Nearside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Offside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Direction indicators not working |1.4.A.2c| | 1 |
| Brake hose damaged | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Front Anti-roll bar rubber mounting bonding deteriorated resulting in excessive movement both sides anti roll bar fail with chassis |2.4.G.2| | 1 |
| Front Upper Anti-roll bar has excessive play in a ball joint both sides |2.4.G.2| | 1 |
| Service brake juddering severely |3.7.C.2| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Upper Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage insecurely attached bolt loose (5.3.3 (a) (i)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Centre Upper Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Front Service brake juddering severely |3.7.C.2| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Offside Rear Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Nearside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Exhaust system insecure tailpipe mount (6.1.2 (a)) | 1 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Anti-roll bar linkage pin or bush likely to become detached (5.3.4 (a) (ii)) | 1 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Rear Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front Anti-roll bar linkage insecure and impairing directional stability top ball joint broken |5.3.3 |a| |ii|| | 1 |
| Offside Front Anti-roll bar linkage insecure and impairing directional stability top ball joint broken |5.3.3 |a| |ii|| | 1 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting bolt missing |2.4.G.1| | 1 |
| Offside Front Outer Front drive shaft coupling is excessively worn |2.5.C.1c| | 1 |
| Offside Front Tie bar/rod insecure |2.4.G.1| | 1 |
| Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Windscreen wiper blade missing |8.2.2| | 1 |
| Steering wheel rim loose (2.2.1 (c) (i)) | 1 |
| Nearside Rear Position lamp likely to become detached (4.2.1 (c) (ii)) | 1 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Rear Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Rear Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Steering box leaking to the extent that oil is dripping (2.1.1 (e) (ii)) | 1 |
| Nearside Rear Brake drum contaminated (1.1.14 (b)) | 1 |
| Central Track rod end ball joint has excessive play pitman arm (2.1.3 (b) (i)) | 1 |
| Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Steering column universal joint insecure |2.1.5| | 1 |
| Front Bumper damaged and likely to cause injury when grazed or contacted N/S & O/S End caps missing (6.1.4 (a) (i)) | 1 |
| Nearside Rear Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced at fuel tank (6.1.1 (c) (i)) | 1 |
| Offside Rear Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced At fuel tank (6.1.1 (c) (i)) | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Inner and outer sides ( at front of tie rod) (6.1.1 (c) (i)) | 1 |
| Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Nearside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced floor pan (7.1.1 (a) (i)) | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced floor pan (7.1.1 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Offside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Nearside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Offside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Rear Service brake effort inadequate at a wheel botk |1.2.1 |a| |i|| | 1 |
| Nearside Direction indicator not working |1.4.A.2c| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Drag link end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Rear Lower Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Lower Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
| Nearside Front Anti-roll bar locating pin retaining device not properly locked |2.4.G.3b| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Centre Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Upper Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |