| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 16 |
| Registration plate lamp issues | 12 |
| Headlamp aim out of alignment | 11 |
| Parking brake: efficiency below requirements |3.7.B.7| | 9 |
| Brake pipe excessively corroded | 6 |
| Rear parking brake recording little or no effort | 6 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 4 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 4 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Registration plate issues | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Battery insecure |1.9.1| | 2 |
| Central Stop lamp not working |1.2.1b| | 2 |
| Centre Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Exhaust has a major leak of exhaust gases center box (6.1.2 (a)) | 1 |
| Offside Front Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Offside Front Drag link end ball joint has excessive play rack end |2.1.3 |b| |i|| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Exhaust has a major leak of exhaust gases centre box and emissions not tested |7.1.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Driver`s airbag obviously defective |5.4.1| | 1 |
| Headlamp insecure |1.7.3| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Offside Lower Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Nearside Upper Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Lower Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Outer sill (6.2.2 (d) (i)) | 1 |
| Rear brake binding | 1 |
| Nearside rear parking |secondary| brake grabbing severely |3.7.B.6b| | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill at front (5.3.6 (a) (i)) | 1 |
| Windscreen wiper blade insecure | 1 |
| Rear brake application uneven | 1 |
| Brakes imbalanced across an axle | 1 |
| Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Central Seat belt webbing significantly weakened o/s |7.1.2 |b| |ii|| | 1 |
| Rear Direction indicator incorrect colour nearside and offside. (4.4.3 (a)) | 1 |
| Nearside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Nearside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Windscreen has damage | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Steering rack gaiter split (2.2.D.2d) | 1 |
| Nearside Rear Brake pipe at imminent risk of failure or fracture (1.1.11 (a)) | 1 |
| Nearside Front Drag link end ball joint dust cover missing (2.2.C.1c) | 1 |
| Offside Front Drag link end ball joint has excessive play (2.2.B.1f) | 1 |
| Nearside Steering rack gaiter split (2.2.D.2d) | 1 |
| Offside Steering rack gaiter insecure (2.2.D.2d) | 1 |
| Nearside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc (2.5.C.1a) | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |