| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 12 |
| Registration plate lamp issues | 9 |
| Brake hose excessively deteriorated | 6 |
| Headlamp aim out of alignment | 6 |
| Front brake disc in such a condition that it is seriously weakened | 5 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
| Brakes imbalanced across an axle | 3 |
| Rear parking brake recording little or no effort | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Rear brake application uneven | 3 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Centre Stop lamp not working |1.2.1b| | 2 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 2 |
| Windscreen has damage | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Power steering pump leaking (2.1.5 (a)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Power steering malfunctioning |2.3.3a| | 1 |
| Nearside Front Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Offside Front Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Registration plate issues | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Offside Rear Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Headlamp light source and lamp not compatible both front (4.1.4 (c)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced out rigger /inner sill (6.1.1 (c) (i)) | 1 |
| Nearside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill (6.1.1 (c) (i)) | 1 |
| Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced outer sill (6.1.1 (c) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases Rear box several blows (6.1.2 (a)) | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Lower Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Direction indicator flashing less than 60 times a minute hazards lights |1.4.A.2g| | 1 |
| Rear Anti-roll bar pin or bush excessively worn n/s/r + o/s/r D bush (5.3.4 (a) (i)) | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint outer |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint outer |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint outer |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint outer |2.4.G.2| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Centre Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Emissions not tested Due to blow (8.2.1.2 (d)) | 1 |
| Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Front Prop shaft likely to become detached |6.1.7 |a| |ii|| | 1 |
| Nearside Rear Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Nearside Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Parking brake lever ratchet mechanism is broken |3.1.5| | 1 |
| Exhaust has a major leak of exhaust gases centre |7.1.2| | 1 |
| Nearside Front Brake hose twisted |3.6.B.4c| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |