| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 14 |
| Headlamp aim out of alignment | 11 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Registration plate lamp issues | 5 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Rear brake binding | 3 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 3 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Battery insecure |1.9.1| | 3 |
| Registration plate issues | 3 |
| Rear brake application uneven | 3 |
| Rear parking brake recording little or no effort | 2 |
| Offside Front Headlamp insecure |1.7.3| | 2 |
| Offside Front Side repeater not working |1.4.A.2c| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Offside Front brake disc excessively pitted |3.5.1h| | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Front drive shaft coupling is excessively worn |2.5.C.1c| | 2 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Nearside Front Headlamp insecure (4.1.1 (c)) | 2 |
| Offside Front drive shaft coupling is excessively worn |2.5.C.1c| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Windscreen wiper blade insecure | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Nearside Rear Shock absorbers insecurely attached detached at top (5.3.2 (a) (i)) | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Side repeater insecure |1.4.A.2b| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded front anchor |2.4.A.3| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded rear shackle |2.4.A.3| | 1 |
| Brakes imbalanced across an axle | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| rear brake excessively fluctuating |3.7.B.3| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Brake hose has insufficient room to move | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Fuel cap/sealing device ineffective wont open |6.1.3 |b| |i|| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
| Nearside Rear Anti-roll bar linkage corroded and seriously weakened |2.4.G.1| | 1 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Offside Front Seat belt anchorage prescribed area is inadequately repaired outer sill (7.1.1 (a) (i)) | 1 |
| Offside Rear Service brake excessively binding binding after application then release of the parking brake (1.2.1 (f)) | 1 |
| Electrical wiring insecure and connectors likely to become disconnected battery positive terminal is deteriorated/insecure (4.11 (a) (ii)) | 1 |
| Nearside Front Headlamp aim not tested unable to test due to headlamp being insecure (4.1.2 (b)) | 1 |
| Offside Seat belt anchorage prescribed area is inadequately repaired outer sill repair panel not repaired/attached to the required standard (7.1.1 (a) (i)) | 1 |
| Nearside Seat belt anchorage prescribed area is inadequately repaired outer sill repair panel not repaired/attached to the required standard (7.1.1 (a) (i)) | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill holed and corroded (7.1.1 (a) (i)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Nearside Front Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Trailing arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Fuel hose leaking |7.2.3| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |