Most common failures | No# failures |
---|
Parking brake: efficiency below requirements |3.7.C.1b| | 23 |
Registration plate lamp issues | 20 |
Headlamp aim out of alignment | 17 |
Brake pipe excessively corroded | 15 |
Windscreen wiper does not clear the windscreen effectively | 13 |
Parking brake lever has no reserve travel |3.1.6b| | 11 |
Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 10 |
Rear parking brake recording little or no effort | 9 |
Offside Front constant velocity joint gaiter split |2.5.C.1a| | 6 |
Parking brake: efficiency below requirements |3.7.B.7| | 5 |
Battery insecure |1.9.1| | 5 |
Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 4 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
Offside Rear Stop lamp not working |1.2.1b| | 3 |
Registration plate issues | 3 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Nearside Rear Stop lamp not working |1.2.1b| | 3 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 3 |
Service brake: efficiency below requirements |3.7.C.1a| | 3 |
Centre Stop lamp not working |1.2.1b| | 3 |
Exhaust system not adequately supported |7.1.1| | 3 |
Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
Brake hose excessively deteriorated | 3 |
Offside Wheel nut|s| missing |4.2.A.1e| | 2 |
Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Obligatory mirror missing |8.1.1| | 2 |
Offside Rear fog lamp not working |1.3.2b| | 2 |
Rear brake disc in such a condition that it is seriously weakened | 2 |
Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 2 |
Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Nearside Stop lamp not working |1.2.1b| | 2 |
Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
Anti-lock braking system warning lamp indicates an ABS fault | 2 |
Brakes imbalanced across an axle | 2 |
Front brake disc in such a condition that it is seriously weakened | 2 |
Offside Rear brake disc excessively pitted |3.5.1h| | 2 |
Service brake: efficiency below requirements |3.7.B.7| | 2 |
Offside Rear Wheel nut|s| missing |4.2.A.1e| | 2 |
Horn not working |1.6.2a| | 2 |
Windscreen has damage | 2 |
Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Side repeater not working |1.4.A.2c| | 2 |
Rear Exhaust system not adequately supported |7.1.1| | 2 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Centre Steering damper leaking oil |2.2.C.1f| | 1 |
Dipswitch operation does not deflect all main beam headlamps to make them dipped beams |1.7.4b| | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Rear Fuel system component leaking |7.2.3| | 1 |
Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Wheel nut|s| missing |4.2.A.1e| | 1 |
Nearside Rear Lower Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Lower Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
Fuel cap/sealing device missing |7.2.4a| | 1 |
Nearside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
Brake fluid contaminated (1.8 (a)) | 1 |
Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded inner sill. |5.2.6| | 1 |
Offside Front Brake pipe excessively chafed |3.6.B.2c| | 1 |
Offside Front Brake pipe seriously damaged |found during steering lock to lock check| |2.2.D.2b| | 1 |
Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
Brake hose has insufficient room to move | 1 |
Nearside Front Drag link end ball joint has excessive play at road wheel |2.2.B.1f| | 1 |
Centre Front Drag link end ball joint has excessive play at steering box |2.2.B.1f| | 1 |
Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Horn not working (7.7 (a) (ii)) | 1 |
Offside Front Shock absorbers has a serious fluid leak | 1 |
Offside Rear Brake pipe leaking on an air braking system Corroded (1.1.11 (b) (i)) | 1 |
Nearside Lower Seat belt anchorage prescribed area strength or continuity significantly reduced Inner sill/wheel arch (7.1.1 (a) (i)) | 1 |
Offside Lower Seat belt anchorage prescribed area strength or continuity significantly reduced Inner sill (7.1.1 (a) (i)) | 1 |
Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Brake performance not tested (1.2.1 (g)) | 1 |
Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc retaining clip missing |2.5.C.1a| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner sill |6.1.B.2| | 1 |
Nearside Front Headlamp has a product on the lens so that the light output is severely reduced |4.1.4 |b|| | 1 |
Offside Front Headlamp has a product on the lens so that the light output is severely reduced |4.1.4 |b|| | 1 |
Nearside Front Obligatory mirror missing |3.3 |a|| | 1 |
Offside Rear Exhaust system insecure (6.1.2 (a)) | 1 |
Offside Rear Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
Emissions not tested (8.2.1.2 (d)) | 1 |
Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Offside Front Lower Seat belt anchorage prescribed area strength or continuity significantly reduced Inner sill excessively corroded (7.1.1 (a) (i)) | 1 |
Offside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
Nearside Front Headlamp aim beam image obviously incorrect bulb holder loose |1.8.A.1b| | 1 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
Headlamp light source and lamp not compatible O/S & N/S |4.1.4 |c|| | 1 |
Offside Front Position lamp light intensity significantly reduced |4.2.3 |a| |ii|| | 1 |
Front Direction indicator incorrect colour O/S & N/S - End flashers |501A bulbs| |4.4.3 |a|| | 1 |
Rear Torque/reaction arm has a deteriorated rubber mounting resulting in excessive movement |2.4.G.2| | 1 |
Offside Front constant velocity joint is insecure |2.5.C.1b| | 1 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
Offside Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Centre Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside All position lamps not working |1.1.A.3b| | 1 |
Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Obligatory mirror insecure |8.1.1| | 1 |
Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Braking system leaking |3.6.A.1| | 1 |
Offside Front brake caliper has restricted free movement |3.5.1k| | 1 |
Nearside Rear Lower Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Lower Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Offside Front Obligatory mirror seriously deteriorated, affecting the rear view drivers door |8.1.2a| | 1 |
Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
Offside rear brake juddering severely |3.7.A.5b| | 1 |
Nearside Rear Trailing arm corroded and seriously weakened |2.4.G.1| | 1 |
Offside Rear Trailing arm corroded and seriously weakened |2.4.G.1| | 1 |
Centre Exhaust mounting missing |7.1.1b| | 1 |
Nearside Rear Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Outer Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Centre Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Front Upper Axle swivel joint has excessive play in a ball joint |2.5.A.3b| | 1 |
Offside Front Lower Axle swivel joint has excessive play |2.5.A.3b| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Tie bar/rod rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Tie bar/rod rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
Offside Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Obligatory mirror seriously damaged, affecting the rear view door mirror cracked |8.1.2a| | 1 |
Nearside Front Headlamp insecure |1.7.3| | 1 |
Nearside Front Front position lamp|s| not working fog |1.1.A.3b| | 1 |
Offside Front Front position lamp|s| not working fog |1.1.A.3b| | 1 |
Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Offside Stop lamp not working |1.2.1b| | 1 |
Offside Rear Exhaust has a part missing |7.1.1a| | 1 |
Nearside Rear Upper Torque/reaction arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Brake pipe excessively damaged |3.6.B.2c| | 1 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Fuel cap/sealing device sealing washer torn |7.2.4c| | 1 |
Offside Inner Front Upper Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Upper Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Offside Front Radius arm damaged and seriously weakened |2.4.G.1| | 1 |
Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
Steering damper leaking oil |2.2.C.1f| | 1 |
Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement N/S & O/S Bushes Missing |2.4.G.2| | 1 |
Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Brake pipe leaking on a hydraulic braking system |1.1.11 |b| |ii|| | 1 |
Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Nearside Rear All position lamps adversely affected by the operation of another lamp |4.2.3 |c|| | 1 |
Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
Brake performance not tested |1.2.1 |g|| | 1 |
Nearside Front Upper Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Outer Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Offside Rear Direction indicator not working |4.4.1 |a| |ii|| | 1 |
Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
Service brake is causing the steering wheel to severely pull one way |1.2.1 |b| |i|| | 1 |
Upper Stop lamp not working |1.2.1b| | 1 |
Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |