| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 42 |
| Registration plate lamp issues | 30 |
| Headlamp aim out of alignment | 27 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 21 |
| Windscreen wiper does not clear the windscreen effectively | 14 |
| Parking brake lever has no reserve travel |3.1.6b| | 10 |
| Registration plate issues | 9 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 8 |
| Anti-lock braking system warning lamp indicates an ABS fault | 6 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 6 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 6 |
| Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 5 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 5 |
| Rear parking brake recording little or no effort | 5 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 4 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 4 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Offside Headlamp insecure |1.7.3| | 4 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Exhaust system not adequately supported |7.1.1| | 4 |
| Rear brake disc in such a condition that it is seriously weakened | 4 |
| Brake hose excessively deteriorated | 4 |
| Nearside Rear Stop lamp not working |1.2.1b| | 4 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Emissions not tested |7.0| | 3 |
| Service brake: efficiency below requirements |3.7.C.1a| | 3 |
| Front Steering damper leaking oil |2.2.C.1f| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Horn not working |1.6.2a| | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Brakes imbalanced across an axle | 3 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 3 |
| Windscreen has damage | 2 |
| Nearside Headlamp insecure |1.7.3| | 2 |
| Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 2 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 2 |
| Offside Front Front constant velocity joint is insecure |2.5.C.1b| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Outer Front drive shaft coupling is excessively worn |2.5.C.1c| | 2 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Rear brake disc contaminated by oil |3.5.1h| | 2 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Rear brake application uneven | 2 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Front Panhard rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Body has a sharp edge caused by corrosion bull bar |6.1.C.1| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded inner/outer sill |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded inner/outer sill |5.2.6| | 1 |
| Offside Rear Axle beam has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
| Offside Rear Trailing arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Front Upper Axle swivel joint has excessive play |2.5.A.3b| | 1 |
| Offside Front Lower Axle swivel joint has excessive play |2.5.A.3b| | 1 |
| Nearside Front Upper Axle swivel joint has excessive play |2.5.A.3b| | 1 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear Electrical wiring insecure |1.9.2a| | 1 |
| Front Electrical wiring insecure |1.9.2a| | 1 |
| Offside Rear brake disc contaminated by oil |3.5.1h| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Stop lamp remains on when the brakes are released | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Power steering malfunctioning |2.3.3a| | 1 |
| Power steering fluid level below minimum |2.3.1| | 1 |
| Power steering inoperative |2.3.3a| | 1 |
| Nearside Outer Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Steering damper leaking oil |2.2.C.1f| | 1 |
| Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Front Vehicle structure has excessive corrosion which adversely affects braking or steering Offside and nearside outriggers. |6.1.1 |c| |ii|| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering Chassis by anti roll bar mounting |6.1.1 |c| |ii|| | 1 |
| Body component corroded and likely to cause injury Both sides outer sills corroded. |6.2.1 |a| |i|| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill |7.1.1 |a| |i|| | 1 |
| Offside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill |7.1.1 |a| |i|| | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Exhaust has a major leak of exhaust gases rear tail pipe |6.1.2 |a|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn d bush |5.3.4 |a| |i|| | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn d bush |5.3.4 |a| |i|| | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen |3.5 |a|| | 1 |
| Nearside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Outer Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside rear brake juddering severely |3.7.A.5b| | 1 |
| Offside rear brake juddering severely |3.7.A.5b| | 1 |
| Front Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Coil spring mounting loose |2.4.C.3a| | 1 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Electrical wiring inadequately supported |1.9.2a| | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Offside Outer Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear Shock absorber insecure |2.7.2b| | 1 |
| Fuel cap/sealing device mounting flange/sealing method defective |7.2.4c| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 1 |
| Nearside Front Brake hose leaking |3.6.A.1| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Wheel insecure |4.2.A.1c| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Obligatory mirror insecure |8.1.1| | 1 |
| Offside Rear reflector missing |1.5.1a| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Direction indicators not in good working order |function impaired| |1.5.A1b| | 1 |
| Nearside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Leaf spring anchor bracket corroded and seriously weakened |2.4.B.6d| | 1 |
| Offside Rear Leaf spring anchor bracket corroded and seriously weakened |2.4.B.6d| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear Towbar component excessively corroded |6.6.1| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Front Panhard rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Power steering pump leaking from a failed seal |2.3.3b| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Offside Front Steering box has a significant oil leak |2.2.D.2e| | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Rear Leaf spring deteriorated and seriously weakened |2.4.B.1a| | 1 |
| Offside Rear Leaf spring deteriorated and seriously weakened |2.4.B.1a| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Front brake application uneven | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Central Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Centre Rear Upper Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Leaf spring saddle is fractured |2.4.B.7a| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Front brake disc excessively scored |3.5.1h| | 1 |
| Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Torque/reaction arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Stop lamp excessively deteriorated so that it is not visible from a reasonable distance |1.2.1d| | 1 |