| Most common failures | No# failures |
|---|
| Registration plate issues | 17 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Brake pipe excessively corroded | 8 |
| Headlamp aim out of alignment | 7 |
| Battery insecure |1.9.1| | 6 |
| Brakes imbalanced across an axle | 6 |
| Nearside Side repeater not working |1.4.A.2c| | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Rear fog lamp not working |1.3.2b| | 4 |
| Rear fog lamp switch missing |1.3.1a| | 4 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 4 |
| Rear fog lamp missing |1.3.2a| | 3 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Side repeater not working |1.4.A.2c| | 3 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 3 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Rear fog lamp missing |1.3.2a| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Registration plate lamp issues | 2 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 2 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 2 |
| Offside Rear Statutory seat belt missing |5.1.1| | 2 |
| Front position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front Direction indicator excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 2 |
| Nearside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Rear Passenger`s seat insecure |6.2.A.1| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Centre Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Headlamp light intensity severely reduced both beam patterns incorrect |4.1.4 |a|| | 1 |
| Headlamp aim not tested |4.1.2 |b|| | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Front Drag link end ball joint has excessive play both sides x2 |2.1.3 |b| |i|| | 1 |
| Offside Front Obligatory mirror missing |8.1.1| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Inner Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Inner Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Exhaust silencer likely to become detached Rear exhaust clamp missing (8.1.1 (b) (ii)) | 1 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Rear Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Windscreen washer not working | 1 |
| Nearside Front Obligatory mirror seriously damaged, affecting the rear view |3.3 |b| |ii|| | 1 |
| Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Outer Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Centre Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Intermediate drop arm pivot housing casing has relative movement to chassis/bodywork top bolt has gap between chassis, looks like locating peg not seated in hole or incorrect part (2.1.2 (a) (ii)) | 1 |
| Nearside Front Lower Intermediate drop arm insecure to the extent there is excessive movement at the mountings idler arm bearing has excessive play (2.1.3 (a) (ii)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Rear fog lamp tell tale missing |1.3.1b| | 1 |
| Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Parking brake lever is impeded in its travel |3.1.6c| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Windscreen wiper blade insecure | 1 |
| Front front brake juddering severely |3.7.A.2b| | 1 |
| Offside Front Body component damaged and likely to cause injury Sill panel |6.2.1 |a| |i|| | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Upper Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front brake disc excessively scored |3.5.1h| | 1 |
| Electrical wiring inadequately supported |1.9.2a| | 1 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Steering arm modification unsafe bush worn |2.1.3 |f| |i|| | 1 |
| Offside Steering arm modification unsafe bush worn |2.1.3 |f| |i|| | 1 |