| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 5 |
| Registration plate lamp issues | 2 |
| Brake pipe excessively corroded | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Fuel system component leaking |7.2.3| | 2 |
| Registration plate issues | 2 |
| Horn not working (7.7 (a)) | 1 |
| Hazard warning lamps not fitted (4.4.1 (d)) | 1 |
| Windscreen washer not working | 1 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn D bush (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar linkage fractured (5.3.3 (b) (ii)) | 1 |
| Nearside Side repeater adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Front Inner Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Inner Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Lower Drag link end ball joint has excessive play idler drag link end (2.1.3 (b) (i)) | 1 |
| Nearside Front Steering linkage ball joint ball joint dust cover insecure so that it no longer prevents the ingress of dirt steering idler boot split (2.1.3 (g) (ii)) | 1 |
| Nearside Front Upper Drag link end ball joint has excessive play bush on idler (2.1.3 (b) (i)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Rear fog lamp switch inoperative (4.5.3 (a) (ii)) | 1 |
| Offside Front Outer Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Steering box insecure |2.2.B.1a| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Drag link end damaged and unserviceable |2.2.C.1d| | 1 |
| Nearside Upper Intermediate drop arm insecure bolt insecure |2.2.B.1a| | 1 |
| Centre Exhaust has a major leak of exhaust gases box burst |7.1.2| | 1 |
| Nearside Drag link end ball pin shank loose |2.2.B.1c| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Offside Side repeater adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear reflector missing |1.5.1a| | 1 |
| Offside Rear reflector missing |1.5.1a| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Windscreen wiper does not clear the windscreen effectively | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Steering damper leaking oil |2.2.C.1f| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Brakes imbalanced across an axle | 1 |
| Steering damper leaking oil |2.2.C.1f| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |