MOT History from tests of petrol CHEVROLET KALOSs year 2006

Review the list of common CHEVROLET KALOS failures below or to perform a specific mot history check on your CHEVROLET then use our popular KnowYourCar service

mot history

Pass percent:61.72%

(The average a petrol CHEVROLET KALOS year 2006 passes without issue)

Based on:37,772 MOT Tests

Most common failures	No# failures
Windscreen wiper does not clear the windscreen effectively	2598
Headlamp aim out of alignment	2438
Anti-lock braking system warning lamp indicates an ABS fault	2113
Registration plate lamp issues	1191
Brake pipe excessively corroded	945
Brakes imbalanced across an axle	684
Offside Front position lamp\|s\| not working \|1.1.A.3b\|	609
Nearside Front position lamp\|s\| not working \|1.1.A.3b\|	564
Supplementary Restraint System warning lamp indicates a fault \|5.4.2\|	549
Rear brake binding	411
Offside Front Anti-roll bar linkage has excessive play in a ball joint \|2.4.G.2\|	386
Nearside Front Anti-roll bar linkage has excessive play in a ball joint \|2.4.G.2\|	370
Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement \|2.4.G.2\|	307
Nearside Headlamp not working on dipped beam \|1.7.5a\|	278
Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement \|2.4.G.2\|	271
Offside Headlamp not working on dipped beam \|1.7.5a\|	251
Front brake disc in such a condition that it is seriously weakened	227
Registration plate issues	216
Windscreen washer not working	213
Offside Front Position lamp not working (4.2.1 (a) (ii))	206
Nearside Front Position lamp not working (4.2.1 (a) (ii))	204
Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h))	203
Offside Front Front position lamp\|s\| not working \|1.1.A.3b\|	194
Nearside Front Shock absorber has a serious fluid leak \|2.7.3\|	190
Supplementary restraint system warning lamp indicates a fault (7.1.6 (a))	178
Battery insecure \|1.9.1\|	176
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits \|7.3.D.3\|	169
Nearside Front Front position lamp\|s\| not working \|1.1.A.3b\|	165
Offside front brake binding \|3.7.B.1\|	164
Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement \|2.4.G.2\|	154
Nearside Stop lamp not working \|1.2.1b\|	147
Nearside Headlamp aim beam image obviously incorrect \|1.8.A.1b\|	145
Offside Front Shock absorber has a serious fluid leak \|2.7.3\|	144
Parking brake: efficiency below requirements \|3.7.B.7\|	140
Offside Headlamp aim beam image obviously incorrect \|1.8.A.1b\|	138
Offside Front Service brake excessively binding (1.2.1 (f))	138
Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement \|2.4.G.2\|	124
Nearside Front Service brake excessively binding (1.2.1 (f))	122
Parking brake lever has no reserve travel \|3.1.6b\|	122
Offside Front Track rod end ball joint has excessive play \|2.2.B.1f\|	121
Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i))	118
Offside Front Suspension arm has excessive play in a pin/bush \|2.4.G.2\|	117
Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i))	114
Nearside Rear Service brake excessively binding (1.2.1 (f))	112
Front brake application uneven	112
Nearside Front Track rod end ball joint has excessive play \|2.2.B.1f\|	112
Exhaust emissions carbon monoxide content after 2nd fast idle excessive \|7.3.D.3\|	112
Nearside Front Suspension arm has excessive play in a pin/bush \|2.4.G.2\|	111
Nearside front brake binding \|3.7.B.1\|	108
Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i))	108
Front Exhaust has a major leak of exhaust gases \|7.1.2\|	107
Offside Front front brake binding \|3.7.B.1\|	106
Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i))	105
Offside Rear Shock absorber has a serious fluid leak \|2.7.3\|	104
Offside Front Anti-roll bar has excessive play in a ball joint \|2.4.G.2\|	103
Offside Rear Service brake excessively binding (1.2.1 (f))	102
Nearside Front Headlamp not working on dipped beam \|1.7.5a\|	102
Offside Track rod end ball joint has excessive play \|2.2.B.1f\|	101
Nearside Front Anti-roll bar has excessive play in a ball joint \|2.4.G.2\|	101
Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i))	99
Nearside Front Position lamp not working \|4.2.1 \|a\|\|	98
Offside Obligatory mirror seriously damaged, affecting the rear view \|8.1.2a\|	96
Offside Front Position lamp not working \|4.2.1 \|a\|\|	96
Offside Front Headlamp not working on dipped beam \|1.7.5a\|	89
Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i))	89
Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c))	84
Offside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement \|2.4.G.2\|	84
Front brake excessively fluctuating	84
Windscreen wiper blade insecure	81
Nearside Track rod end ball joint has excessive play \|2.2.B.1f\|	81
Supplementary restraint system warning lamp indicates a fault \|7.1.6 \|a\|\|	78
Rear brake application uneven	78
Engine MIL inoperative or indicates a malfunction \|8.2.1.2 \|h\|\|	78
Rear parking brake recording little or no effort	78
Horn not working \|1.6.2a\|	77
Parking brake efficiency below requirements (1.4.2 (a) (i))	76
Nearside Front front brake binding \|3.7.B.1\|	76
Exhaust emissions carbon monoxide content at idle excessive \|7.3.D.4\|	73
Nearside Front Suspension arm has excessive play in a ball joint \|2.4.G.2\|	73
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` \|8.3.1e\|	72
Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii))	71
Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c))	70
Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i))	69
Exhaust has a major leak of exhaust gases \|7.1.2\|	69
Offside Stop lamp not working \|1.2.1b\|	66
Nearside Front Headlamp aim beam image obviously incorrect \|1.8.A.1b\|	65
Nearside Rear Shock absorber has a serious fluid leak \|2.7.3\|	64
Offside Front Headlamp aim beam image obviously incorrect \|1.8.A.1b\|	61
Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c))	61
Nearside Front Service brake excessively binding \|1.2.1 \|f\|\|	60
Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i))	60
Offside Rear Direction indicator incorrect colour \|1.4.A.2f\|	59
Offside Track rod end ball joint has excessive play (2.1.3 (b) (i))	59
Mechanical brake component has restricted free movement	59
Offside Rear Direction indicator not working \|1.4.A.2c\|	59
Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c))	59
Brake fluid warning lamp illuminated \|3.6.G.2\|	59
Fuel system component leaking \|7.2.3\|	58
Offside Front Suspension arm has excessive play in a ball joint \|2.4.G.2\|	58
Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c))	57
Nearside Rear Direction indicator not working \|1.4.A.2c\|	56
Nearside Stop lamp(s) not working (4.3.1 (a) (ii))	56
Nearside Rear Stop lamp not working \|1.2.1b\|	56
Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii))	56
Offside Front Service brake excessively binding \|1.2.1 \|f\|\|	54
Nearside Front Track rod end ball joint has excessive play \|2.1.3 \|b\| \|i\|\|	54
Offside Front Suspension arm pin or bush excessively worn \|5.3.4 \|a\| \|i\|\|	53
Nearside Front Anti-roll bar linkage ball joint excessively worn \|5.3.4 \|a\| \|i\|\|	52
Offside Front Track rod end ball joint has excessive play \|2.1.3 \|b\| \|i\|\|	51
Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i))	50
Nearside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement \|2.4.G.2\|	49
Windscreen has damage	49
Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i))	47
Anti-lock braking system warning lamp does not illuminate \|3.4.1b\|	46
Nearside Rear Direction indicator incorrect colour \|1.4.A.2f\|	45
Offside Front coil spring broken \|2.4.C.1a\|	45
Offside Front Anti-roll bar linkage ball joint excessively worn \|5.3.4 \|a\| \|i\|\|	44

We get to these numbers by trawling through over 1 billion MOT test results since 2004 and crunched the numbers. We remove anything to do with Tyres, as they are model independent and group together common non-model specific issues. We are trying to get to a picture of what models have what issues.

Please note: We take the data from the DVSA. This data is raw and can contain typos and spelling mistakes that garages may have entered while recording a MOT result. Specifically miss-match on names of models and makes. We are constantly cleaning the data so bear with the odd issue.

Got suggestions? We’re improving this section all the time. If you have any suggestions, please let us know.

MOT History from tests of petrol CHEVROLET KALOSs year 2006

Find us on Facebook