| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 5 |
| Registration plate lamp issues | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Windscreen wiper does not clear the windscreen effectively | 3 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 3 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Brakes imbalanced across an axle | 2 |
| Battery insecure |1.9.1| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Horn not working |1.6.2a| | 2 |
| Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Rear Rear fog lamp missing |1.3.2a| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Front Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Nearside Front Horn not working |1.6.2a| | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Brake pipe excessively corroded | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Front Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Rear brake application uneven | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Hazard warning switch missing |1.4.B.1d| | 1 |
| Nearside Front Driver`s seat insecure |6.2.A.1| | 1 |
| Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Rear Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Registration plate issues | 1 |
| Centre Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Nearside Front Driver`s door does not latch securely closed |6.2.B.1a| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Rear Statutory seat belt missing |5.1.1| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Seat belt affected by an insecure seat fixing drivers |5.2.1b| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Rear fog lamp tell tale missing |1.3.1b| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Rear fog lamp insecure |1.3.2a| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Brake hose excessively deteriorated | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Offside Rear Leaf spring cracked |2.4.B.1a| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Rear Wheel nut|s| loose |4.2.A.1e| | 1 |
| Nearside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Power steering component|s| leaking from a failed seal |2.3.3b| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Rear brake binding | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Nearside Rear brake caliper leaking |3.6.A.1| | 1 |
| Nearside Rear Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Side repeater incorrect colour |1.4.A.2f| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Front Fuel system component leaking |7.2.3| | 1 |