| Most common failures | No# failures |
|---|
| Anti-lock braking system warning lamp indicates an ABS fault | 5 |
| Brakes imbalanced across an axle | 4 |
| Headlamp aim out of alignment | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Service brake: efficiency below requirements |3.7.C.1a| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
| Emissions not tested |7.3.A.1| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Rear brake application uneven | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
| Registration plate lamp issues | 1 |
| Brake pipe excessively corroded | 1 |
| Front Brake pipe leaking on a hydraulic braking system across front subframe (1.1.11 (b) (ii)) | 1 |
| Offside Front Anti-roll bar linkage fractured (5.3.3 (b) (ii)) | 1 |
| Offside Front Subframe mounting prescribed area excessively damaged significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect too faded to project clear image (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect too faded to project image (4.1.2 (c)) | 1 |
| Offside Intermediate drop arm pivot housing casing retaining devices dangerously loose steering idler (2.1.2 (a) (ii)) | 1 |
| Brake performance not tested due to brake pipe leak (1.2.1 (g)) | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Front Side repeater missing |1.4.A.2b| | 1 |
| Offside Front Side repeater missing |1.4.A.2b| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Central Rear Brake pipe leaking on a hydraulic braking system |1.1.11 |b| |ii|| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Brake pipe at imminent risk of failure or fracture (1.1.11 (a)) | 1 |
| Offside Front Brake pipe connection leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Nearside Front Shock absorbers likely to become detached (5.3.2 (a) (ii)) | 1 |
| Offside Front Shock absorbers likely to become detached (5.3.2 (a) (ii)) | 1 |
| Nearside Front Suspension arm likely to fail (5.3.3 (b) (ii)) | 1 |
| Offside Rear Leaf spring saddle is moving relative to the spring (5.3.1 (a) (ii)) | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Front Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Offside Front Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Horn not working |1.6.2a| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Fuel cap/sealing device missing (6.1.3 (b) (i)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Hazard warning switch missing |1.4.B.1d| | 1 |
| Rear Exhaust has a major leak of exhaust gases missing |7.1.2| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Position lamp showing white light to the rear |4.2.3 |a| |ii|| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Offside front brake juddering severely |3.7.A.2b| | 1 |
| Nearside Outer Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Registration plate issues | 1 |
| Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Side repeater missing |1.4.A.2b| | 1 |
| Offside Side repeater missing |1.4.A.2b| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Rear fog lamp has less than 50% of the light sources illuminating |1.3.2b| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Rear Service brake grabbing severely (1.2.1 (c)) | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Exhaust system insecure tail pipe corroded and mounting broken (6.1.2 (a)) | 1 |
| Offside Steering linkage ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Front Exhaust system insecure pipe (6.1.2 (a)) | 1 |
| Nearside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Offside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |