| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 24 |
| Rear parking brake recording little or no effort | 14 |
| Parking brake lever has no reserve travel |3.1.6b| | 8 |
| Rear brake binding | 7 |
| Service brake: efficiency below requirements |3.7.B.7| | 6 |
| Headlamp aim out of alignment | 6 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 5 |
| Horn not working |1.6.2a| | 4 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 3 |
| Registration plate lamp issues | 3 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
| Driver`s seat insecure |6.2.A.1| | 2 |
| Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Front Braking system leaking |3.6.A.1| | 2 |
| Brakes imbalanced across an axle | 2 |
| Windscreen washer control missing |8.2.1a| | 2 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Rear Direction indicators incorrect colour Both sides |1.4.A.2f| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Rear Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings above body mount |6.1.B.2| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Nearside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Nearside Front Upper Front suspension locking device missing |2.5.A.4| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Front position lamp|s| not working sidelight |1.1.A.3b| | 1 |
| Steering column will not lock in a fixed position |adjustable type| |2.1.2a| | 1 |
| Nearside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Front Lower Steering column flexible coupling is excessively deteriorated |2.1.5| | 1 |
| Nearside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Power steering pipe|s| or hose|s| leaking at pump
|2.3.3b| | 1 |
| Nearside Rear Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Suspension arm locating pin insecure missing |2.4.G.3a| | 1 |
| Offside Front Suspension arm synthetic bush deteriorated resulting in excessive movement missing |2.4.G.2| | 1 |
| Front passenger seat insecure |6.2.3| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Power steering ram|s| leaking from a failed component |2.3.3b| | 1 |
| Nearside Front Power steering pipe|s| or hose|s| fouling other parts of the vehicle |2.3.2| | 1 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Brake hose excessively deteriorated | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Front brake application uneven | 1 |
| Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Drive shaft which forms part of the suspension support bearing excessively worn |2.4.G.4d| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Nearside Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Parking brake lever is impeded in its travel |3.1.6c| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Fuel cap/sealing device sealing washer deteriorated split |7.2.4c| | 1 |
| Offside Front brake caliper leaking |3.6.A.1| | 1 |
| Nearside Rear Drive shaft which forms part of the suspension support bearing excessively worn excessive play in diff |2.4.G.4d| | 1 |
| Offside Rear Drive shaft which forms part of the suspension support bearing excessively worn excessive play in diff |2.4.G.4d| | 1 |
| Nearside Front Exhaust has a major leak of exhaust gases manifold area |7.1.2| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Rear Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Front Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
| Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Offside Front Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Bonnet primary retaining device ineffective unable to open bonnet (3.1 (c)) | 1 |
| Brake lever has abnormal movement of levers indicating excessive wear or maladjustment handbrake high (1.1.15 (f)) | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front brake caliper leaking |3.6.A.1| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings bracket |6.1.B.2| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Braking system leaking flexi pipe |3.6.A.1| | 1 |
| Nearside Rear Tie bar/rod rubber bush deteriorated resulting in excessive movement strut rod inner bush |2.4.G.2| | 1 |
| Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Nearside Side repeater missing |1.4.A.2b| | 1 |
| Offside Side repeater missing |1.4.A.2b| | 1 |
| Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Front Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |