Most common failures | No# failures |
---|
Windscreen wiper does not clear the windscreen effectively | 22 |
Registration plate lamp issues | 16 |
Offside Rear fog lamp not working |1.3.2b| | 12 |
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 11 |
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 11 |
Headlamp aim out of alignment | 9 |
Registration plate issues | 7 |
Brakes imbalanced across an axle | 7 |
Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 6 |
Rear fog lamp not working |1.3.2b| | 6 |
Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 6 |
Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 5 |
Parking brake: efficiency below requirements |3.7.B.7| | 5 |
Brake pipe excessively corroded | 4 |
Rear parking brake recording little or no effort | 4 |
Offside Rear Stop lamp not working |1.2.1b| | 4 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 4 |
Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 3 |
Parking brake lever has no reserve travel |3.1.6b| | 3 |
Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 3 |
Anti-lock braking system warning lamp indicates an ABS fault | 3 |
Offside Rear fog lamp missing |1.3.2a| | 3 |
Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 3 |
Nearside Rear Stop lamp not working |1.2.1b| | 3 |
Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 3 |
Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 2 |
Nearside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
Offside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
Rear brake application uneven | 2 |
Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |
Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 2 |
Brake pedal spongy |3.3.B.1b| | 2 |
Nearside Front Shock absorber insecure |2.7.2b| | 2 |
Offside Rear fog lamp insecure |1.3.2a| | 2 |
Rear fog lamp missing |1.3.2a| | 2 |
Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 2 |
Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Brake hose excessively deteriorated | 2 |
Nearside Stop lamp not working |1.2.1b| | 2 |
Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
Offside Stop lamp not working |1.2.1b| | 2 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
Rear Rear fog lamp not working |1.3.2b| | 2 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Stop lamp remains on when the brakes are released | 2 |
Windscreen has damage | 2 |
Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
Brake fluid significantly below minimum mark (1.1.10 (d) (ii)) | 1 |
Brake pipe leaking on a hydraulic braking system rear around fuel tank to front [2.5] (1.1.11 (b) (ii)) | 1 |
Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Exhaust emissions exceed manufacturers specified limit manufactures plate limit is 0.86 (8.2.2.2 (a)) | 1 |
Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Offside Front brake caliper securing device missing |3.5.1j| | 1 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
Nearside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Front brake caliper securing device loose |3.5.1j| | 1 |
Offside Front brake caliper securing device loose |3.5.1j| | 1 |
Nearside Rear Leaf spring shackle pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Offside Rear Leaf spring shackle pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
Windscreen washer not working | 1 |
Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
Offside Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
Nearside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
Nearside Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
Nearside Rear Shock absorbers has a serious fluid leak | 1 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Windscreen wiper not working |3.4 |a|| | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Body has a sharp edge caused by damage mirror casing
|6.1.C.1| | 1 |
Nearside Front Brake hose twisted |3.6.B.4c| | 1 |
Offside Rear position lamp|s| insecure |1.1.A.3a| | 1 |
Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Offside Front All position lamps not working |1.1.A.3b| | 1 |
Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Front Shock absorbers insecurely attached |5.3.2 |a| |i|| | 1 |
Nearside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
Offside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
Offside Side repeater not working |1.4.A.2c| | 1 |
Nearside Front Ball joint has excessive play track rod end |2.2.B.1f| | 1 |
Offside Front Ball joint has excessive play track rod end |2.2.B.1f| | 1 |
Mechanical brake component has restricted free movement | 1 |
Trailer electrical socket (13 pin) not operating the trailer lamps as intended (1.9.4) | 1 |
Nearside Stop lamp not working (1.2.1b) | 1 |
Front brake disc excessively scored (3.5.1h) | 1 |
Offside Rear fog lamp not working (1.3.2b) | 1 |
Rear fog lamp tell tale not working (1.3.1b) | 1 |
Nearside Front Body has a sharp edge caused by damage (6.1.C.1) | 1 |
Offside Front Body has a sharp edge caused by damage (6.1.C.1) | 1 |
Parking brake: efficiency below requirements (3.7.B.7) | 1 |
Offside Rear rear parking (secondary) brakes imbalanced low/ no effort (3.7.B.6b) | 1 |
Rear fog lamp not working (1.3.2b) | 1 |
Offside Front Anti-roll bar linkage has excessive play in a ball joint (2.4.G.2) | 1 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Nearside Side repeater incorrect colour (4.4.3 (a)) | 1 |
Exhaust emissions exceed manufacturers specified limit Plate limit 0.63 (8.2.2.2 (a)) | 1 |
Nearside Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Offside Front Shock absorbers has a serious fluid leak | 1 |
Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
Exhaust has a major leak of exhaust gases front pipe broken (6.1.2 (a)) | 1 |
Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
Rear fog lamp emits a light other than red |1.3.2e| | 1 |
Rear fog lamp insecure |1.3.2a| | 1 |
Nearside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
Nearside Rear Leaf spring anchor pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Offside Rear Leaf spring anchor pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Front Steering system excessively tight |2.2.D.1| | 1 |
Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Rear fog lamp tell tale not working |1.3.1b| | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Lower Steering column universal joint has excessive play |2.1.5| | 1 |
Offside Brake pipe seriously damaged |found during steering lock to lock check| |2.2.D.2b| | 1 |
Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Rear Towbar component fractured |6.6.1| | 1 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Rear Vehicle structure fractured seriously affecting its strength within 30cm of towbar mounting |6.6.6| | 1 |
Rear Towbar component insecure |6.6.1| | 1 |
Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Driver`s seat insecure |6.2.A.1| | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis rail by spring mounting (5.3.6 (a) (i)) | 1 |
Central Exhaust has a major leak of exhaust gases box and joints blowing (6.1.2 (a)) | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Offside Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Rear Lower Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Rear fog lamp has a product on the lens so it is not visible from a reasonable distance |1.3.2d| | 1 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 1 |
Offside Front Track rod end ball joint worn to the extent there is a serious risk of detachment (2.1.3 (b) (ii)) | 1 |
Central Upper Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Central Exhaust has a major leak of exhaust gases Tailpipe on upper surface at junction to rear box (6.1.2 (a)) | 1 |
Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
Nearside Inner Ball joint has excessive play rack |2.2.B.1f| | 1 |
Nearside Front Body has a sharp edge caused by damage bumper |6.1.C.1| | 1 |
Nearside Rear fog lamp not working |1.3.2b| | 1 |