| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 20 |
| Rear parking brake recording little or no effort | 12 |
| Headlamp aim out of alignment | 11 |
| Horn not working |1.6.2a| | 8 |
| Parking brake lever has no reserve travel |3.1.6b| | 6 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 5 |
| Nearside Stop lamp not working |1.2.1b| | 5 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 4 |
| Registration plate lamp issues | 4 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 4 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 4 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 3 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 3 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 3 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 3 |
| Hazard warning switch faulty |1.4.B.1d| | 3 |
| Nearside Front brake caliper leaking |3.6.A.1| | 3 |
| Windscreen wiper does not clear the windscreen effectively | 3 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 2 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 2 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Steering damper leaking oil |2.2.C.1f| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Rear brake caliper leaking |3.6.A.1| | 2 |
| Nearside Front Braking system leaking |3.6.A.1| | 2 |
| Offside Rear brake caliper leaking |3.6.A.1| | 2 |
| Brakes imbalanced across an axle | 2 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Windscreen has damage | 2 |
| Steering column flexible coupling is excessively deteriorated |2.1.5| | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Rear brake binding | 2 |
| Rear fog lamp missing |1.3.2a| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 2 |
| Offside Front Lower Headlamp not working on main beam MAIN BEAM UNIT INOPERATIVE |1.7.5a| | 1 |
| Exhaust emissions carbon monoxide content excessive EMISSIONS CO HIGH [6.50]% |7.3.B.1a| | 1 |
| Front brake application uneven | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Offside Front Front passenger door cannot be opened from outside the vehicle left hand drive (6.2.3 (a)) | 1 |
| Offside Front Front passenger door cannot be opened from inside the vehicle left hand drive (6.2.3 (a)) | 1 |
| Nearside Front Outer Headlamp insecure (4.1.1 (c)) | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Front Upper Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear Radius arm locating pin insecure |2.4.G.3a| | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Rear Trailing arm attachment bracket/mounting nut missing |2.4.G.1| | 1 |
| Nearside Rear Trailing arm attachment bracket/mounting nut missing |2.4.G.1| | 1 |
| Offside Inner Rear Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
| Nearside Rear Stop lamp|s| lens defective such that the emitted light is adversely affected |4.3.1 |b| |ii|| | 1 |
| Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.3 |a|| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Oil leaking excessively from transmission (8.4.1 (a) (i)) | 1 |
| Offside Front Front position lamp|s| flickers when tapped lightly by hand |1.1.4c| | 1 |
| Steering column flexible coupling has excessive play |2.1.5| | 1 |
| Offside Front Headlamp insecure |4.1.1 |c|| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear brake disc contaminated by brake fluid |3.5.1h| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Front Hydraulic brake calliper leaking |1.1.16 |b| |i|| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Front passenger seat cannot be secured in the upright position. |6.2.4| | 1 |
| Offside Front brake caliper leaking |3.6.A.1| | 1 |
| Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Rear fog lamp adversely affected by the operation of another lamp |1.3.2f| | 1 |
| Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Nearside Direction indicator not working |1.4.A.2c| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Brake hose excessively deteriorated | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Nearside Front Steering locking device missing |2.2.C.1g| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Rear fog lamp tell-tale missing (4.9.1 (a) (ii)) | 1 |
| Headlamp not working on dipped beam both (4.1.1 (a) (ii)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Power steering malfunctioning |2.3.3a| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Nearside Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Rear reflector missing |1.5.1a| | 1 |
| Centre Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
| Registration plate issues | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside Rear Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Windscreen washer not working | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Nearside Rear Suspension rod insecurely attached locking nuts (5.3.3 (a) (i)) | 1 |
| Offside Rear Suspension rod insecurely attached locking nuts (5.3.3 (a) (i)) | 1 |
| Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp flashing red as well as amber (4.4.3 (b)) | 1 |
| Offside Rear Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp flashing red as well as amber (4.4.3 (b)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Brake pipe excessively corroded | 1 |
| Nearside Rear Suspension arm locating pin retaining device missing |2.4.G.3b| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Nearside rear parking |secondary| brake grabbing severely |3.7.B.6b| | 1 |
| Offside rear parking |secondary| brake grabbing severely |3.7.B.6b| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Front Intermediate drop arm insecure |2.2.B.1a| | 1 |
| Brake hose damaged | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Parking |secondary brake| on a single line braking system has inadequate effort at a wheel |1.3.1 |a| |i|| | 1 |
| Offside Rear Hydraulic brake calliper leaking and braking performance affected |1.1.16 |b| |ii|| | 1 |
| Offside Rear Brake disc contaminated |1.1.14 |b|| | 1 |
| Brake performance not tested |1.2.1 |g|| | 1 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Front Steering system has excessive free play detected at the steering wheel |steering box fitted| Drop arm |2.2.A.1a| | 1 |
| Brake cable has restricted free movement |3.5.1k| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` Sunvisor does not stow away |8.3.1e| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Offside Braking system leaking caliper |3.6.A.1| | 1 |
| Brake performance not tested due to caliper leak |3.7.A.1| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Rear Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |