| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 21 |
| Brake pipe excessively corroded | 17 |
| Registration plate issues | 14 |
| Windscreen wiper does not clear the windscreen effectively | 13 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 11 |
| Offside Rear fog lamp not working |1.3.2b| | 10 |
| Rear fog lamp tell tale not working |1.3.1b| | 9 |
| Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 8 |
| Brake hose excessively deteriorated | 8 |
| Brakes imbalanced across an axle | 7 |
| Battery insecure |1.9.1| | 6 |
| Offside Rear fog lamp missing |1.3.2a| | 5 |
| Nearside Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 5 |
| Front passenger seat cannot be secured in the upright position. |6.2.4| | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Registration plate lamp issues | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Horn not working |1.6.2a| | 4 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Offside Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 3 |
| Hazard warning switch faulty |1.4.B.1d| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Front Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Rear brake application uneven | 2 |
| Nearside Front Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 2 |
| Front brake excessively fluctuating | 2 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Front Anti-roll bar linkage fractured |2.4.G.1| | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Stop lamp not working |1.2.1b| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Brake pipe inadequately clipped |3.6.B.1| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Main beam `tell-tale` not working |1.7.4c| | 2 |
| Nearside Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill (7.1.1 (a) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill (7.1.1 (a) (i)) | 1 |
| Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Centre Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Trailing arm locating pin insecure |2.4.G.3a| | 1 |
| Offside Outer Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Steering column top mounting bracket insecure |2.1.2d| | 1 |
| Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Offside Front passenger seat cannot be secured in the upright position. |6.2.4| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Front coil spring fractured |2.4.C.1a| | 1 |
| Nearside Rear Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Rear Anti-roll bar synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Offside Rear Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner arch (5.3.6 (a) (i)) | 1 |
| Windscreen washer not working | 1 |
| Nearside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Front Steering component mounting prescribed area is fractured |2.2.C.1h| | 1 |
| Offside Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Radius arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Radius arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Nearside Inner Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
| Offside Inner Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
| Front brake application uneven | 1 |
| front brakes release unevenly |3.7.B.4| | 1 |
| Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Front Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Front Front passenger seat cannot be secured in the upright position. |6.2.4| | 1 |
| Nearside Side repeater insecure |1.4.A.2b| | 1 |
| Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Emissions not tested |7.0| | 1 |
| Inner Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Additional braking device insecure |3.6.I.1| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Upper Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front Side repeater excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Nearside Front coil spring incomplete |2.4.C.1a| | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Rear fog lamp tell tale missing |1.3.1b| | 1 |
| Nearside Rear brake drum contaminated by oil |3.5.1h| | 1 |
| Offside Front Shock absorber insecure |2.7.2b| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Dipswitch operation does not extinguish all main beam headlamps leaving at least one pair of dipped beam headlamps |1.7.4b| | 1 |
| Offside Front Lower Brake performance not tested |3.7.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced wheel arch requires welding in two places (7.1.1 (a) (i)) | 1 |
| Steering column has excessive movement up and down (2.2.2 (a)) | 1 |
| Offside Front Lower Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Rear Exhaust has a major leak of exhaust gases Before axle. |7.1.2| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Centre Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Drivers seat backrest cannot be secured in the upright position. (6.2.5 (b) (ii)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Power steering pump leaking (2.1.5 (a)) | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Rear Anti-roll bar pin or bush excessively worn both d bush |5.3.4 |a| |i|| | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill |5.3.6 |a| |i|| | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill |5.3.6 |a| |i|| | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength arch |5.3.6 |a| |i|| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced floor |7.1.1 |a| |i|| | 1 |
| Offside Front Inner Brake master cylinder/servo mounting prescribed area is excessively corroded arch |1.1.21 |e| |i|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Offside Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front front brakes release unevenly |3.7.B.4| | 1 |
| Nearside Front Seat belt not functioning as intended |7.1.2 |c|| | 1 |
| Offside Front Seat belt not functioning as intended |7.1.2 |c|| | 1 |
| Nearside Rear Seat belt not functioning as intended |7.1.2 |c|| | 1 |
| Offside Rear Seat belt not functioning as intended |7.1.2 |c|| | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturer`s specified limits |8.2.1.2 |b|| | 1 |
| Nearside Front Headlamp light intensity severely reduced |4.1.4 |a|| | 1 |
| Offside Front Headlamp light intensity severely reduced |4.1.4 |a|| | 1 |
| Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Offside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Horn emits two or more alternating tones |1.6.2d| | 1 |
| Steering column retaining device insecure |2.1.6| | 1 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Anti-roll bar insecure |2.4.G.1| | 1 |
| Nearside Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 1 |
| Nearside Front brake disc excessively scored |3.5.1h| | 1 |
| Offside Front brake disc excessively scored |3.5.1h| | 1 |
| Front Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Power steering pump leaking from a failed seal |2.3.3b| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Side repeater missing |1.4.A.2b| | 1 |
| Nearside Side repeater missing |1.4.A.2b| | 1 |
| Nearside Front Coil spring not correctly located |2.4.C.2| | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Nearside Front Anti-roll bar linkage cracked |2.4.G.1| | 1 |
| Offside Front Anti-roll bar linkage cracked |2.4.G.1| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Centre Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Horn control missing |1.6.1| | 1 |
| Offside Passenger`s seat insecure |6.2.A.1| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |