| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 19 |
| Parking brake: efficiency below requirements |3.7.B.7| | 19 |
| Registration plate issues | 17 |
| Rear parking brake recording little or no effort | 16 |
| Brakes imbalanced across an axle | 13 |
| Rear fog lamp tell tale not working |1.3.1b| | 11 |
| Offside Rear fog lamp not working |1.3.2b| | 10 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Horn not working |1.6.2a| | 9 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 8 |
| Registration plate lamp issues | 7 |
| Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 7 |
| Rear fog lamp not working |1.3.2b| | 7 |
| Brake pipe excessively corroded | 6 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Battery insecure |1.9.1| | 5 |
| Parking brake lever has no reserve travel |3.1.6b| | 5 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 4 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 4 |
| Exhaust system not adequately supported |7.1.1| | 4 |
| Offside Side repeater not working |1.4.A.2c| | 4 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 4 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 4 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Rear fog lamp missing |1.3.2a| | 3 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Indicator tell tale inoperative |1.4.A.2a| | 3 |
| Rear brake binding | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Hazard warning switch missing |1.4.B.1d| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Brake hose excessively deteriorated | 3 |
| Nearside Side repeater not working |1.4.A.2c| | 3 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 3 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 3 |
| Rear brake application uneven | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 2 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Front coil spring fractured |2.4.C.1a| | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Steering column top bearing excessively worn |2.1.2c| | 2 |
| Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 2 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 2 |
| Rear Braking system leaking |3.6.A.1| | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Windscreen washer not working | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Rear fog lamp switch missing |1.3.1a| | 2 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Hazard warning switch faulty |1.4.B.1d| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 2 |
| Windscreen wiper blade insecure | 2 |
| Offside Front passenger seat cannot be secured in the upright position. |6.2.4| | 2 |
| Rear Exhaust mounting missing |7.1.1b| | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Front passenger seat cannot be secured in the upright position. |6.2.4| | 2 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 2 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Offside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Offside Rear fog lamp missing |1.3.2a| | 2 |
| Nearside Rear brake drum contaminated by oil |3.5.1h| | 1 |
| Steering column top mounting bracket insecure |2.1.2d| | 1 |
| Offside Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Offside Rear Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Windscreen wiper blade missing |8.2.2| | 1 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Offside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Centre Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Rear rear brake juddering severely |3.7.A.5b| | 1 |
| Offside Rear rear brake juddering severely |3.7.A.5b| | 1 |
| Rear Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Wheel nut|s| loose |4.2.A.1e| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration (8.2.1.2 (g)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Front Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage fractured |5.3.3 |b| |ii|| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Rear fog lamp tell tale missing |1.3.1b| | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Steering wheel retaining device insecure |2.1.6| | 1 |
| Centre Rear fog lamp not visible from a reasonable distance |1.1.6b| | 1 |
| Rear Rear fog lamp missing |1.3.2a| | 1 |
| Rear fog lamp has less than 50% of the light sources illuminating |1.3.2b| | 1 |
| Offside Outer Obligatory mirror insecure |8.1.1| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Hazard warning switch insecure |1.4.B.1d| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Rear Shock absorber insecure |2.7.2b| | 1 |
| Nearside Front Driver`s seat insecure |6.2.A.1| | 1 |
| Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings body at inner wheel arch |6.1.B.2| | 1 |
| Offside Front Anti-roll bar linkage missing |2.4.G.1| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front Seat belt stitching badly frayed |5.2.2b| | 1 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Nearside rear brake juddering severely |3.7.A.5b| | 1 |
| Offside rear brake juddering severely |3.7.A.5b| | 1 |
| Nearside front brake juddering severely |3.7.A.2b| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Front Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Inner Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front passenger seat cannot be secured in the upright position. |6.2.4| | 1 |
| Nearside Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Anti-roll bar linkage severely distorted |2.4.G.1| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Front position lamp|s| insecure |1.1.A.3a| | 1 |
| Centre Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Horn not working Bad connection on button (7.7 (a) (ii)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage fractured (5.3.3 (b) (ii)) | 1 |
| Offside Rear Anti-roll bar linkage fractured (5.3.3 (b) (ii)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Headlamp not working on main beam drivers side (4.1.1 (a) (ii)) | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Nearside Rear Anti-roll bar linkage cracked |2.4.G.1| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Headlamp aim so that beam "kick up" is not visible on the screen NS + OS |4.1.2 |a|| | 1 |
| Position lamp showing red light to the front NS + OS |4.2.3 |a| |ii|| | 1 |
| Battery insecure and likely to cause a short circuit |4.13 |a| |ii|| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front position lamp|s| incorrect colour red |1.1.A.3e| | 1 |
| Nearside Front Direction indicator incorrect colour white |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour white |1.4.A.2f| | 1 |
| Power steering pipe|s| or hose|s| leaking from a seal |2.3.3b| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded floor pan |5.2.6| | 1 |
| Exhaust has a major leak of exhaust gases lots of holes front to rear |7.1.2| | 1 |
| Speedometer clearly inoperative cable not connected |6.7.2| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced dip beam |1.7.5a| | 1 |
| Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded rear mount, inner sill |2.4.A.3| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded rear mount, inner sill |2.4.A.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded shock absorber top mount, inner arch |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded Trailing arm front mount, inner arch |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded trailing arm front mount, inner arch |2.4.A.3| | 1 |
| Offside Outer Front Headlamp not working on main beam |1.7.5a| | 1 |
| Stop lamp|s| with a multiple light source more than 1/2 not functioning High level |4.3.1 |a| |ii|| | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| Offside Ball joint has excessive play |2.2.B.1f| | 1 |
| Brake master cylinder fluid level below minimum level |3.6.G.1e| | 1 |
| Nearside Rear Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.B.1| | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Headlamp aim not tested due to no head lights (4.1.2 (b)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Nearside Rear Rear reflector more than 50% obscured |1.5.1b| | 1 |
| Offside Rear reflector more than 50% obscured |1.5.1b| | 1 |
| Offside Front Upper Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Front Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Nearside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Offside Front Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch |5.3.6 |a| |i|| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Offside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Nearside Front front brake grabbing severely |3.7.A.2b| | 1 |
| Offside Front front brake grabbing severely |3.7.A.2b| | 1 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear wheel bearing has excessive play |2.6.2| | 1 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Front Suspension has inadequate clearance with the chassis |2.4.A.1a| | 1 |
| Offside Front Suspension has inadequate clearance with the chassis |2.4.A.1a| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front coil spring cracked |2.4.C.1a| | 1 |
| Offside Front coil spring cracked |2.4.C.1a| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |