| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 42 |
| Registration plate issues | 26 |
| Parking brake: efficiency below requirements |3.7.B.7| | 20 |
| Rear parking brake recording little or no effort | 16 |
| Offside Rear fog lamp not working |1.3.2b| | 14 |
| Rear fog lamp not working |1.3.2b| | 13 |
| Brakes imbalanced across an axle | 10 |
| Rear fog lamp tell tale not working |1.3.1b| | 10 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 10 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 9 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 8 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 7 |
| Registration plate lamp issues | 6 |
| Rear brake binding | 5 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Parking brake lever has no reserve travel |3.1.6b| | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Horn not working |1.6.2a| | 5 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 4 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 4 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 3 |
| Exhaust emissions hydrocarbon content excessive |8.2.1.2 |b|| | 3 |
| Windscreen washer not working | 3 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
| Nearside Rear Stop lamp not working |1.2.1b| | 3 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 3 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 3 |
| Side repeater missing |1.4.A.2b| | 3 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 3 |
| Nearside Side repeater missing |1.4.A.2b| | 3 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Nearside Headlamp not working on main beam |1.7.5a| | 3 |
| Hazard warning switch faulty |1.4.B.1d| | 3 |
| Fuel system component leaking |7.2.3| | 3 |
| Brake hose excessively deteriorated | 3 |
| Horn not working (7.7 (a)) | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Offside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 2 |
| Brake hose has insufficient room to move | 2 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Offside Side repeater missing |1.4.A.2b| | 2 |
| Horn control missing |1.6.1| | 2 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Obligatory mirror missing |8.1.1| | 2 |
| Offside Front Direction indicator not working |1.4.A.2c| | 2 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Steering system excessively rough |2.2.D.1| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 2 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 2 |
| Fuel system component leaking (6.1.3 (b) (i)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect offside beam kick up to the offside |4.1.2 |c|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Rear Brake cable insecure | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear Fuel hose excessively damaged |7.2.2| | 1 |
| Fuel pipe union leaking (6.1.3 (b) (i)) | 1 |
| Offside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Exhaust catalytic converter missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
| Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Offside Rear Position lamp adversely affected by the operation of another lamp Flashes when indicator switched on (4.2.3 (c)) | 1 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Rear Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Offside Front Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Rear Torsion bar excessive play at an end fixing |2.4.E.2| | 1 |
| Nearside Rear Anti-roll bar linkage cracked |2.4.G.1| | 1 |
| Nearside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Side repeater missing |1.4.A.2b| | 1 |
| Offside Front Side repeater missing |1.4.A.2b| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Rear Brake cable locking device missing |3.5.1l| | 1 |
| Offside Rear Shock absorber casing damaged externally so the unit does not function |2.7.2a| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Lower Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Electrical wiring insecure under-dash |1.9.2a| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| An item not tested |Manual| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Rear brake application uneven | 1 |
| Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
| Front Anti-roll bar fractured |2.4.G.1| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear fog lamp not working |1.3.2b| | 1 |
| Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Rear Tie bar/rod attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp aim beam image too far to the left |1.6.B4| | 1 |
| Nearside Rear Lower Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Steering wheel locking device insecure steering wheel feels inscure |2.1.6| | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Offside Rear All position lamps not working |1.1.A.3b| | 1 |
| Nearside Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Position lamp switch allows the rear position lamps to be switched off when the headlamps are on (4.2.2 (a)) | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Coil spring mounting insecure to the extent that relative movement is visible |5.3.1 |a| |ii|| | 1 |
| Offside Front Coil spring mounting insecure to the extent that relative movement is visible |5.3.1 |a| |ii|| | 1 |
| Nearside Rear Coil spring mounting insecure to the extent that relative movement is visible |5.3.1 |a| |ii|| | 1 |
| Offside Rear Coil spring mounting insecure to the extent that relative movement is visible |5.3.1 |a| |ii|| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
| Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Brake cable guide defective and affecting operation rubbing on drive shaft (1.1.15 (d)) | 1 |
| Nearside Steering rack gaiter missing |2.2.D.2d| | 1 |
| Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Nearside Front Fluid suspension unit leaking |2.4.D.2| | 1 |
| Nearside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Direction indicators not working |1.4.A.2c| | 1 |
| Offside Direction indicators not working |1.4.A.2c| | 1 |
| Obligatory mirror missing |3.3 |a|| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Centre Obligatory mirror missing |8.1.1| | 1 |
| Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Obligatory mirror missing |3.3 |a|| | 1 |
| Windscreen washer control missing |8.2.1a| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Centre Exhaust has a part missing |7.1.1a| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Offside Rear Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Brake cable insecure |3.5.1d| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Offside Rear Tie bar/rod attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Nearside Rear Suspension weakened allowing body or other component to foul a road wheel or would do so if laden |2.4.A.1b| | 1 |
| Offside Rear Suspension weakened allowing body or other component to foul a road wheel or would do so if laden |2.4.A.1b| | 1 |
| Fuel system component leaking fuel pipe at tank (6.1.3 (b) (i)) | 1 |
| Brake fluid warning lamp inoperative |3.6.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Road wheel cracked |4.2.A.1a| | 1 |
| rear brake grabbing severely |3.7.A.5b| | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Rear Axle insecure such that stability is impaired (5.1.1 (b) (ii)) | 1 |