| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 63 |
| Registration plate lamp issues | 16 |
| Windscreen wiper does not clear the windscreen effectively | 15 |
| Brake pipe excessively corroded | 14 |
| Anti-lock braking system warning lamp indicates an ABS fault | 7 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 7 |
| Registration plate issues | 7 |
| Rear brake disc in such a condition that it is seriously weakened | 6 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 5 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 4 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 4 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 4 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 3 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 3 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 3 |
| Brakes imbalanced across an axle | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Rear brake binding | 3 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 3 |
| Rear parking brake recording little or no effort | 3 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Emissions not tested |7.0| | 2 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Offside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Rear Rear fog lamp missing |1.3.2a| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Rear Exhaust has a major leak of exhaust gases EMISSIONS NOT TESTED |7.1.2| | 1 |
| Rear brake application uneven | 1 |
| Nearside Rear Seat belt damaged |7.1.2 |b| |i|| | 1 |
| Nearside Windscreen damaged and affecting the driver`s view of the road |3.2 |a| |ii|| | 1 |
| Nearside Front Macpherson strut has excessive movement in the upper support bearing assembly |2.5.B.1b| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Offside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Nearside Rear Shock absorbers has an excessively worn bush top mount (5.3.2 (c)) | 1 |
| Offside Rear Shock absorbers has an excessively worn bush top mount (5.3.2 (c)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Brake hose excessively deteriorated | 1 |
| Fuel tank insecure Retaining straps weakened due to excessive corrosion |6.1.3 |a| |i|| | 1 |
| Exhaust silencer insecure Rear mountings defective |8.1.1 |b| |i|| | 1 |
| Offside Front Wheel bearing play so excessive it is likely to break up |5.1.3 |a| |ii|| | 1 |
| Offside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Offside Front Brake hose damaged and likely to fail |1.1.12 |a|| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear bush |5.3.4 |a| |i|| | 1 |
| Offside Front Position lamp not working side |4.2.1 |a|| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Coil spring not correctly located |2.4.C.2| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Nearside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Nearside Headlamp light source and lamp not compatible (4.1.4 (c)) | 1 |
| Offside Headlamp light source and lamp not compatible (4.1.4 (c)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Front Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Nearside Front Suspension has inadequate clearance with the chassis Coil spring fouling body |2.4.A.1a| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Exhaust shield missing where fitted as original equipment creating a risk of fire Insecure (6.1.3 (e)) | 1 |
| Steering system excessively rough |2.2.D.1| | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Track rod end ball joint worn to the extent there is a serious risk of detachment |2.1.3 |b| |ii|| | 1 |
| Offside Front Track rod end ball joint worn to the extent there is a serious risk of detachment |2.1.3 |b| |ii|| | 1 |
| Nearside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Central Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
| Offside Rear Position lamp light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
| Anti-lock braking system warning lamp does not illuminate (1.6 (a)) | 1 |
| Nearside Front Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Front Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Front Suspension component corroded and seriously weakened Components (5.3.3 (b) (i)) | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Offside Front Torque/reaction arm has a deteriorated rubber bush resulting in excessive movement (2.4.G.2) | 1 |
| Nearside Rear brake disc excessively pitted (3.5.1h) | 1 |
| Offside Rear brake disc excessively pitted (3.5.1h) | 1 |
| Offside Front Front wheel bearing rough when rotated (2.5.A.2) | 1 |
| Offside Front Front wheel bearing has excessive play (2.5.A.3c) | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Inner Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Fuel cap/sealing device ineffective |6.1.3 |b| |i|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Supplementary restraint system warning lamp indicates a fault air bag light on (7.1.6 (a)) | 1 |
| Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front Power steering component|s| leaking from a failed seal |2.3.3b| | 1 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Front Inner Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Offside Front position lamp|s| obscured more than 50% |1.1.A.3c| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear wishbone bush |5.3.4 |a| |i|| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Front brake excessively fluctuating | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Fuel cap/sealing device ineffective rubber split |6.1.3 |b| |i|| | 1 |
| Rear fog lamp tell-tale not working |4.9.1 |a| |ii|| | 1 |