| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 47 |
| Registration plate issues | 25 |
| Windscreen wiper does not clear the windscreen effectively | 13 |
| Nearside Rear Shock absorbers has a serious fluid leak | 11 |
| Offside Rear Shock absorbers has a serious fluid leak | 8 |
| Offside Front Shock absorbers has a serious fluid leak | 8 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 7 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 7 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 6 |
| Nearside Front Shock absorbers has a serious fluid leak | 5 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 5 |
| Windscreen has damage | 4 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 4 |
| Brake hose excessively deteriorated | 4 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 3 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 2 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 2 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Registration plate lamp issues | 2 |
| Windscreen washer not working | 2 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 2 |
| Bonnet cannot be secured in the closed position |8.4.1| | 2 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 2 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Offside Front Road wheel cracked |4.2.A.1a| | 2 |
| Nearside Front Headlamp light intensity severely reduced |4.1.4 |a|| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn front most arm inner bush (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn front most arm inner bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt rear most (5.3.4 (b) (ii)) | 1 |
| Central Front Lower Exhaust emissions likely to be affected by an exhaust leak (8.2.2.1 (b)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Prop shaft joint excessively worn (6.1.7 (c) (i)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension arm has excessive play in a pin/bush outer bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Offside Headlamp not working on dipped beam (1.7.5a) | 1 |
| Vehicle Identification Number has more than one different number displayed |6.3.5.b| | 1 |
| Front Headlamp lens seriously defective n/s and o/s (4.1.1 (b) (ii)) | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Front Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt Wishbone. |2.4.G.2| | 1 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Rear All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect dip (4.1.2 (c)) | 1 |
| Brakes imbalanced across an axle | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Rear Lower Suspension component pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Suspension arm attachment bracket/mounting corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Sub-frame attachment bracket/mounting fractured (5.3.3 (b) (ii)) | 1 |
| Nearside Rear Sub-frame attachment bracket/mounting fractured (5.3.3 (b) (ii)) | 1 |
| Offside Front Brake drum back plate insecure (1.1.14 (d)) | 1 |
| Nearside Front Road wheel cracked |4.2.A.1a| | 1 |
| Nearside Front Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Nearside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Nearside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area is fractured osr chassis holed by mounting point |2.4.A.3| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Outer Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Lower Suspension arm ball joint excessively worn outer joint (5.3.4 (a) (i)) | 1 |
| Offside Rear Lower Suspension arm ball joint excessively worn outer joint (5.3.4 (a) (i)) | 1 |
| Brake lining|s| wear indicator illuminated |1.1.13 |a| |i|| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Fuel pipe leaking at pressure regulator |7.2.3| | 1 |
| Exhaust particulate filter missing where one was fitted as standard |7.1.3| | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Brake performance not tested |3.7.A.1| | 1 |
| Rear Brake lining(s) less than 1.5 mm thick (1.1.13 (a) (ii)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Road wheel fractured (5.2.2 (a)) | 1 |
| Nearside Rear Sub-frame attachment bracket/mounting likely to become detached corroded (5.3.3 (a) (ii)) | 1 |
| Offside Rear Sub-frame attachment bracket/mounting likely to become detached corroded (5.3.3 (a) (ii)) | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Emissions unable to be completed not carried out emissions due to oil leak. (8.2.2.2 (e)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Position lamp switch does not operate in accordance with the requirements Light switch completely inoperable (4.2.2 (a)) | 1 |
| Nearside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength arm from body to subframe |5.3.6 |a| |i|| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Lower Suspension arm has excessive play in a pin/bush hub bush |2.4.G.2| | 1 |
| Position lamp switch cannot be operated from the normal driving position (4.2.2 (b)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Offside Rear Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Exhaust emits excessive smoke or vapour of any colour (7.4.B.4) | 1 |
| Offside Headlamp aim unable to be tested (4.1.2 (b)) | 1 |
| Exhaust emissions exceed manufacturers specified limit Plate value 0.50 (8.2.2.2 (a)) | 1 |
| Nearside Rear Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Rear Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Road wheel cracked |4.2.A.1a| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn Top rearmost arm outer bush excessively worn. (5.3.4 (a) (i)) | 1 |
| Nearside Front Macpherson strut top bush or bearing has excessive wear or free play (5.3.4 (a) (i)) | 1 |
| Nearside Front Inner Road wheel cracked right through a previous weld repair |4.2.A.1a| | 1 |
| Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt front |2.4.G.2| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt rear |2.4.G.2| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Rear Inner Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Direction indicator light intensity significantly reduced (4.4.3 (a)) | 1 |
| Nearside Front Brake pipe connection leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.2.2 |g|| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Emissions unable to be completed (8.2.2.2 (e)) | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear coil spring broken |2.4.C.1a| | 1 |
| Offside Rear coil spring broken |2.4.C.1a| | 1 |
| Nearside Rear Sub-frame corroded and seriously weakened hole in rear frame NSF corner above mount (5.3.3 (b) (i)) | 1 |
| Offside Rear Sub-frame corroded and seriously weakened hole in rear frame OSF corner above mount (5.3.3 (b) (i)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Suspension arm severely distorted |2.4.G.1| | 1 |
| Nearside Front Road wheel fractured old repair cracked (5.2.2 (a)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Nearside Rear Suspension component attachment bracket/mounting corroded and seriously weakened sub frame brace to floor (5.3.3 (b) (i)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Brake cable damaged broken (1.1.15 (a)) | 1 |
| Front Exhaust system insecure (6.1.2 (a)) | 1 |
| Offside Rear Road wheel fractured (5.2.2 (a)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Windscreen damaged and affecting the drivers view of the road (3.2 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Shock absorbers insecurely attached (5.3.2 (a) (i)) | 1 |
| Headlamp levelling device inoperative Broken (4.1.5 (a)) | 1 |