| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 76 |
| Rear parking brake recording little or no effort | 52 |
| Headlamp aim out of alignment | 20 |
| Registration plate lamp issues | 19 |
| Windscreen wiper does not clear the windscreen effectively | 17 |
| Parking brake lever has no reserve travel |3.1.6b| | 12 |
| Brake pipe excessively corroded | 12 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 8 |
| Offside Rear fog lamp not working |1.3.2b| | 7 |
| Rear fog lamp not working |1.3.2b| | 6 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 5 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Rear fog lamp tell tale not working |1.3.1b| | 5 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Rear brake binding | 5 |
| Nearside Front coil spring fractured |2.4.C.1a| | 5 |
| Brakes imbalanced across an axle | 4 |
| Offside Front coil spring incomplete |2.4.C.1a| | 4 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 4 |
| Registration plate issues | 4 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 4 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 4 |
| Offside Rear coil spring fractured |2.4.C.1a| | 4 |
| Nearside Rear coil spring broken |2.4.C.1a| | 4 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 3 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 3 |
| Nearside Rear Fluid suspension has no suspension movement |2.4.D.5| | 3 |
| Offside Rear Fluid suspension has no suspension movement |2.4.D.5| | 3 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 3 |
| Offside Rear Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 3 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 3 |
| Power steering component|s| leaking |2.3.3b| | 3 |
| Windscreen washer not working | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Front coil spring fractured |2.4.C.1a| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 2 |
| Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 2 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
| Offside Front Braking system leaking |3.6.A.1| | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Centre Statutory seat belt missing |5.1.1| | 2 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
| Fuel pipe leaking |7.2.3| | 2 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Power steering pump leaking from a failed component |2.3.3b| | 2 |
| Rear Brake valve leaking |3.6.A.1| | 2 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.5 |b| |i|| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Nearside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 2 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 2 |
| Nearside Rear coil spring cracked |2.4.C.1a| | 2 |
| Offside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Nearside Front Side repeater not working |1.4.A.2c| | 2 |
| Offside Rear Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Rear Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Fluid suspension pipe leaking |2.4.D.2| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Offside Outer Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Central Rear Seat belt buckle missing middle seat set (7.1.2 (d)) | 1 |
| Central Rear Seat belt buckle not functioning as intended middle seat set (7.1.2 (d)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Brake pivot has restricted free movement |3.5.1k| | 1 |
| Offside Rear Brake pivot has restricted free movement |3.5.1k| | 1 |
| Spare wheel carrier insecure |6.4.2| | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Outer Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Outer Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Windscreen wiper not working |3.4 |a|| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Rear Fuel system component leaking |7.2.3| | 1 |
| Power steering ram|s| leaking from a failed component |2.3.3b| | 1 |
| Rear Fluid suspension unit deteriorated and likely to fail both (2.4.D.1b) | 1 |
| Exhaust emissions carbon monoxide content excessive (7.3.B.1a) | 1 |
| Nearside Headlamp not working on dipped beam (1.7.5a) | 1 |
| Horn not working |1.6.2a| | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Brake warning device not identifying low pressure |1.1.4 |a| |ii|| | 1 |
| Rear fog lamp tell-tale not working |4.9.1 |a| |ii|| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Nearside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Offside Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Nearside Rear Trailing arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Rear Trailing arm inappropriately repaired |2.4.A.2| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| brake caliper leaking both sides front 1 caliper ,leaking |3.6.A.1| | 1 |
| Offside Outer Front Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Fuel cap/sealing device ineffective fuel flap wont open |6.1.3 |b| |i|| | 1 |
| Offside Front Steering locking device missing track rod end |2.2.C.1g| | 1 |
| Nearside Rear Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Nearside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Brake linkage has restricted free movement |3.5.1k| | 1 |
| Shock absorber has negligible damping effect |2.7.5| | 1 |
| Front Hydraulic fluid leaking excessively Dripping from underside engine bay (8.4.1 (a) (i)) | 1 |
| Nearside Rear Suspension unit leaking (5.3.5 (c)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Brake cable has a seized clevis joint pivot |3.5.1c| | 1 |
| Offside Brake cable has a seized clevis joint pivot |3.5.1c| | 1 |
| Outer Brake cable has a seized clevis joint pivot |3.5.1c| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Lower Steering column universal joint insecure |2.1.5| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill. (5.3.6 (a) (i)) | 1 |
| Offside Front Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill. (5.3.6 (a) (i)) | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Headlamp aim not tested |4.1.2 |b|| | 1 |
| Power steering pump leaking from a failed joint |2.3.3b| | 1 |
| Nearside Rear Fluid suspension unit leaking |2.4.D.2| | 1 |
| Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Rear Suspension arm corroded and seriously weakened Spring cup. |2.4.G.1| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Nearside Rear Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Front Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Centre Rear Seat belt adjustment fitting badly deteriorated |5.2.3| | 1 |
| Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Suspension component leaking Floor pan area (5.3.5 (c)) | 1 |
| Power steering component leaking Nearside rack boot (2.1.5 (a)) | 1 |
| Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| coil spring incomplete |2.4.C.1a| | 1 |
| Offside Front Fluid suspension unit fouled by moving parts likely to cause damage |2.4.D.1c| | 1 |
| Nearside Outer Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Rear Brake linkage has abnormal movement of levers indicating excessive wear |3.5.1f| | 1 |
| Offside Rear Brake linkage has abnormal movement of levers indicating excessive wear |3.5.1f| | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Centre Rear Statutory seat belt missing |5.1.1| | 1 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Inner Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Rear coil spring broken |2.4.C.1a| | 1 |
| Nearside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Centre Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Bootlid cannot be secured in the closed position |6.4.1| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Centre Front Braking system leaking |3.6.A.1| | 1 |
| Brake warning device not working correctly |3.3.D.3a| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Upper Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear coil spring cracked |2.4.C.1a| | 1 |
| Nearside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Centre Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| Nearside Front Inner Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Power steering pipe|s| or hose|s| leaking from a seal |2.3.3b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Front Shock absorber has an excessively worn bush lower ball joint |2.7.4| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Nearside Front coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Rear Radius arm corroded and seriously weakened |2.4.G.1| | 1 |
| Rear Brake pipe kinked |3.6.B.2b| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Offside Front Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Bumper likely to become detached |6.1.4 |a| |ii|| | 1 |
| Brake hydraulic reservoir fluid level significantly below minimum level |1.1.10 |d| |ii|| | 1 |
| Offside Front Undertray likely to become detached |6.2.1 |a| |ii|| | 1 |
| Parking brake lever ratchet not holding correctly |1.1.6 |a|| | 1 |
| Offside Front Position lamp adversely affected by the operation of another lamp |4.2.3 |c|| | 1 |
| Power steering ram leaking |2.1.5 |a|| | 1 |
| Nearside Front Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded Outer sill |2.4.A.3| | 1 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded Outer sill |2.4.A.3| | 1 |
| Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
| Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front coil spring cracked |2.4.C.1a| | 1 |
| Nearside Front coil spring broken |2.4.C.1a| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Rear Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |