Most common failures | No# failures |
---|
Parking brake: efficiency below requirements |3.7.B.7| | 38 |
Headlamp aim out of alignment | 28 |
Rear parking brake recording little or no effort | 25 |
Registration plate lamp issues | 15 |
Windscreen wiper does not clear the windscreen effectively | 15 |
Brake pipe excessively corroded | 14 |
Parking brake lever has no reserve travel |3.1.6b| | 8 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 6 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 6 |
Offside Front Direction indicator not working |1.4.A.2c| | 5 |
Rear brake binding | 4 |
Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 3 |
Offside Stop lamp not working |1.2.1b| | 3 |
Nearside Rear Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 3 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 3 |
Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 3 |
Nearside Front Direction indicator not working |1.4.A.2c| | 3 |
Rear fog lamp not working |1.3.2b| | 3 |
Parking brake lever ratchet mechanism is broken |3.1.5| | 3 |
Nearside Rear Shock absorbers has a serious fluid leak | 3 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 2 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Front coil spring broken |2.4.C.1a| | 2 |
Nearside Front Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Offside Front Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Brakes imbalanced across an axle | 2 |
Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Headlamp not working on main beam |1.7.5a| | 2 |
Centre Stop lamp not working |1.2.1b| | 2 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
Rear fog lamp tell tale not working |1.3.1b| | 2 |
Offside Rear Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 2 |
Offside Rear Brake linkage has restricted free movement |3.5.1k| | 2 |
Nearside Rear Parking brake lever has no reserve travel |3.1.6b| | 2 |
Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Nearside Front Braking system leaking |3.6.A.1| | 2 |
Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
Nearside Front Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Front Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Front brake disc in such a condition that it is seriously weakened | 1 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Brake hose connection leaking on an air braking system |1.1.12 |c| |i|| | 1 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
Power steering ram|s| leaking from a failed seal |2.3.3b| | 1 |
Offside Front brake caliper leaking |3.6.A.1| | 1 |
Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Rear brake disc in such a condition that it is seriously weakened | 1 |
Nearside Front front brake juddering severely |3.7.A.2b| | 1 |
Offside Front front brake juddering severely |3.7.A.2b| | 1 |
Nearside Front Steering locking device missing |2.2.C.1g| | 1 |
Offside Front Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
Offside Front Braking system leaking |3.6.A.1| | 1 |
Offside Parking brake lever has no reserve travel |3.1.6b| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 1 |
Nearside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
Offside Inner Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Windscreen washer not working | 1 |
Windscreen wiper blade insecure | 1 |
Brake warning device not working correctly |3.3.D.3a| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Service brake: efficiency below requirements |3.7.B.7| | 1 |
Rear Air suspension has no suspension movement |2.4.D.5| | 1 |
Nearside Front Coil spring missing and directional control affected |5.3.1 |c| |ii|| | 1 |
Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
Horn sounds harsh or grating |1.6.2e| | 1 |
Nearside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
Brake pipe inappropriately repaired |3.6.A.3| | 1 |
Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Front front brake binding |3.7.B.1| | 1 |
Power steering component|s| leaking from a failed seal |2.3.3b| | 1 |
Battery insecure |1.9.1| | 1 |
Power steering pipe/hose leaking |2.1.5 |a|| | 1 |
Nearside Front Suspension accumulator leaking |5.3.5 |c|| | 1 |
Brake hose leaking on a hydraulic braking system |1.1.12 |c| |ii|| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Front Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
Power steering inoperative |2.3.3a| | 1 |
Offside Front brake disc contaminated by oil |3.5.1h| | 1 |
Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
Offside Outer Seat belt anchorage prescribed area is excessively corroded sill panel |5.2.6| | 1 |
Offside Front Hazard warning lamps inoperative |1.4.B.1b| | 1 |
Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Rear Gas suspension has no suspension movement |2.4.D.5| | 1 |
Offside Rear Gas suspension has no suspension movement |2.4.D.5| | 1 |
Nearside Rear Brake linkage has restricted free movement |3.5.1k| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Front coil spring broken |2.4.C.1a| | 1 |
Nearside Stop lamp not working |1.2.1b| | 1 |
Offside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
Offside Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Outer Headlamp not working on main beam |1.7.5a| | 1 |
Rear Fluid suspension has no suspension movement |2.4.D.5| | 1 |
Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
Nearside Rear Headlamp flickers when tapped lightly by hand |1.2.4c| | 1 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Inner Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Inner Steering locking device missing |2.2.C.1g| | 1 |
Offside Front Macpherson strut insecure |2.4.G.1| | 1 |
Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
Central Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Centre Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Power steering malfunctioning |2.3.3a| | 1 |
Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Parking brake lever releases when knocked |3.1.6a| | 1 |
Nearside Rear Lower Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Windscreen has damage | 1 |
Offside Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
Nearside Rear Coil spring mounting corroded and seriously weakened (5.3.1 (b) (i)) | 1 |
Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Brake fluid significantly below minimum mark (1.1.10 (d) (ii)) | 1 |
Nearside Headlamp aim beam image kick up to the offside (1.8) | 1 |
Offside Headlamp aim beam image kick up to the offside (1.8) | 1 |
Front brake application uneven | 1 |
Parking brake: efficiency below requirements (3.7.B.7) | 1 |
Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
Nearside Front Suspension component leaking (5.3.5 (c)) | 1 |
Rear Brake valve leaking (1.1.7 (a) (i)) | 1 |
Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Offside Front Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
Brake performance not tested (1.2.1 (g)) | 1 |
Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
Offside Front Shock absorbers has a serious fluid leak | 1 |
Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Nearside Rear Inner Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
Offside Rear Inner Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
Nearside Front Inner Seat belt buckle missing (7.1.2 (d)) | 1 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Central Front Inner Steering locking device missing ALL FOUR SPLIT PIN LOCKING DEVICES MISSING. (2.1.3 (d)) | 1 |
Nearside Rear Hydraulic brake cylinder leaking hydraulic fluid caliper (1.1.16 (b) (i)) | 1 |
Offside Rear Hydraulic brake cylinder leaking hydraulic fluid caliper (1.1.16 (b) (i)) | 1 |
Windscreen wiper not working (3.4 (a)) | 1 |
Exhaust Lambda reading after 2nd fast idle outside specified limits reading1.040 (8.2.1.2 (c)) | 1 |
Offside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Nearside Side repeater incorrect colour (4.4.3 (a)) | 1 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Headlamp not working on main beam inner (4.1.1 (a) (ii)) | 1 |