| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Brakes imbalanced across an axle | 7 |
| Offside Rear fog lamp not working |1.3.2b| | 5 |
| Registration plate lamp issues | 5 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 5 |
| Brake pipe excessively corroded | 4 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Headlamp aim out of alignment | 3 |
| Brake hose excessively deteriorated | 3 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 3 |
| Rear brake binding | 2 |
| Horn not working |1.6.2a| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Rear Rear fog lamp obscured more than 50% |1.3.2c| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Front Macpherson strut has excessive play in the sliding bush or gland |2.5.B.1b| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Fuel system component leaking filter (6.1.3 (b) (i)) | 1 |
| Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Drivers seat backrest cannot be secured in the upright position. (6.2.5 (b) (ii)) | 1 |
| Passengers seat backrest cannot be secured in the upright position. (6.2.6 (a) (i)) | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded marked yellow (2.1.2 (e) (i)) | 1 |
| Nearside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Drivers view of the road through the swept area of the windscreen materially affected by an obstruction visor (3.1 (a) (ii)) | 1 |
| Central Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Windscreen washer not working | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded step |5.2.6| | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded crossmember/chassis rail |2.2.C.1h| | 1 |
| Nearside Side repeater obviously incorrectly positioned and o/s not visible 1m from rear bumper (4.4.3 (a)) | 1 |
| Offside Body component damaged and likely to cause injury side panel missing (6.2.1 (a) (i)) | 1 |
| Exhaust emissions carbon monoxide content excessive 8.5 vs 3.5 max (8.2.1.2 (b)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Rear Lower Leaf spring shackle pin or bush excessively worn and upper (5.3.4 (a) (i)) | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded a post (1.1.21 (e) (i)) | 1 |
| Fuel hose leaking filler neck (6.1.3 (b) (i)) | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Driver`s seat insecure |6.2.5 |a| |ii|| | 1 |
| Passenger`s seat insecure |6.2.6 |a| |ii|| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Chassis/wheel arch |5.3.6 |a| |i|| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Chassis |5.3.6 |a| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Chassis |5.3.6 |a| |i|| | 1 |
| Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Wheel arch |5.3.6 |a| |i|| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Nearside Steering locking device missing Track rod end split pin |2.1.3 |d|| | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Horn not working (7.7 (a)) | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Offside Rear Rear fog lamp obviously incorrectly positioned Rear fog lamp insecure to the extent that the lamp does not face to the rear (4.5.4 (a)) | 1 |
| Fuel tank leaking (6.1.3 (b) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Rear most shackle excessively corroded (5.3.6 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Outer sill (6.1.1 (c) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Outer/inner sill (6.1.1 (c) (i)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Inner arch front most (6.1.1 (c) (i)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Outer sill (6.1.1 (c) (i)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Inner sill (6.1.1 (c) (i)) | 1 |
| Nearside Steering arm deformed and unserviceable |2.2.C.1d| | 1 |
| Rear brake application uneven | 1 |
| Drivers seat insecure (6.2.5 (a) (ii)) | 1 |
| Passengers seat insecure (6.2.6 (a) (ii)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Foot well/ door shut area (6.1.1 (c) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Foot well/ door shut area (6.1.1 (c) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Fuel system component leaking Fuel filler neck leaking (6.1.3 (b) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively damaged significantly reducing structural strength Front most axle mount (5.3.6 (a) (i)) | 1 |
| Offside Front Lower Suspension arm corroded and seriously weakened Bent and corroded (5.3.3 (b) (i)) | 1 |
| Offside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Upper Suspension component mounting prescribed area fractured significantly reducing structural strength top mount (5.3.6 (a) (i)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting centre chassis (6.2.2 (d) (i)) | 1 |
| Nearside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner (7.1.1 (a) (i)) | 1 |
| Nearside Front Outer Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Direction indicators adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Centre Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Nearside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Inner Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Outer Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Sill (6.1.1 (c) (i)) | 1 |
| Offside Outer Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Sill (6.1.1 (c) (i)) | 1 |
| Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Floor, under O/S carpet (6.1.1 (c) (i)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced door step and A pillar (6.1.1 (c) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced door step (6.1.1 (c) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced outer sill (6.1.1 (c) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner arch forward section (6.1.1 (c) (i)) | 1 |
| Central Front Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt steering arm (2.1.3 (g) (ii)) | 1 |