| Most common failures | No# failures |
|---|
| Brakes imbalanced across an axle | 24 |
| Headlamp aim out of alignment | 17 |
| Registration plate lamp issues | 16 |
| Windscreen wiper does not clear the windscreen effectively | 11 |
| Rear parking brake recording little or no effort | 9 |
| Brake pipe excessively corroded | 8 |
| Rear brake application uneven | 8 |
| Service brake: efficiency below requirements |3.7.B.7| | 7 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 7 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
| Hazard warning switch faulty |1.4.B.1d| | 5 |
| Nearside Rear Stop lamp not working |1.2.1b| | 5 |
| Stop lamp not working |1.2.1b| | 5 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Driver`s seat insecure |6.2.A.1| | 4 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Rear brake binding | 4 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 3 |
| Horn not working |1.6.2a| | 3 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 3 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 3 |
| Offside Headlamp not working on main beam |1.7.5a| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 3 |
| Front brake application uneven | 3 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 3 |
| Fuel tank leaking |7.2.3| | 3 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 3 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 2 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 2 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Body insecure and dangerous to other road users |6.1.B.1b| | 2 |
| Brake has no servo assistance |3.3.B.2| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 2 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
| Nearside rear brake grabbing severely |3.7.A.5b| | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
| Position lamp switch faulty |1.1.A.1| | 2 |
| Nearside Front front brake recording little or no effort |3.7.B.5a| | 2 |
| Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Shock absorber has negligible damping effect |2.7.5| | 2 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Fuel system component leaking |7.2.3| | 2 |
| Front Sub-frame inappropriately repaired |2.4.A.2| | 2 |
| Offside Obligatory mirror insecure |8.1.1| | 2 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Registration plate issues | 2 |
| rear parking |secondary| brakes imbalanced | 2 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Suspension component mounting prescribed area is severely distorted |2.4.A.3| | 1 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Nearside Rear Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Fluid leak harmful to the environment or a risk to other road users diesel from upper engine |8.4.1 |a| |i|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Nearside Front Lower Shock absorber detached |2.7.2b| | 1 |
| Central Exhaust system not adequately supported |7.1.1| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Rear Direction indicator obscured more than 50% |1.4.A.2d| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Passenger`s seat insecure |6.2.A.1| | 1 |
| Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Nearside front brake grabbing severely |3.7.A.2b| | 1 |
| Offside front brake grabbing severely |3.7.A.2b| | 1 |
| Offside rear brake grabbing severely |3.7.A.5b| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Rear front brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Nearside Rear Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Upper Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Rear Wheel nut|s| loose |4.2.A.1e| | 1 |
| Offside Rear Wheel nut|s| loose |4.2.A.1e| | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Nearside Front Steering locking device insecure |2.2.C.1g| | 1 |
| Offside Front Steering locking device insecure |2.2.C.1g| | 1 |
| Nearside Front Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Offside Rear fog lamp adversely affected by the operation of another lamp |1.3.2f| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Rear All position lamps adversely affected by the operation of another lamp |4.2.3 |c|| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Statutory seat belt missing |5.1.1| | 1 |
| Front Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Front Shock absorber insecure |2.7.2b| | 1 |
| Offside Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Offside Front Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
| Front Electrical wiring deteriorated and bare wires exposed behind bumper |1.9.2c| | 1 |
| Electrical wiring inadequately supported radio |1.9.2a| | 1 |
| Electrical wiring damaged, likely to cause a short drivers side under dashboard |1.9.2b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Offside Rear fog lamp insecure |1.3.2a| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Windscreen wiper blade missing |8.2.2| | 1 |
| Nearside Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Rear position lamp|s| insecure |1.1.A.3a| | 1 |
| Nearside Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Rear Vehicle structure is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Shock absorber insecure |2.7.2b| | 1 |
| Offside Front Shock absorber insecure |2.7.2b| | 1 |
| Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion arch |6.1.C.1| | 1 |
| Exhaust has a major leak of exhaust gases tailbox |7.1.2| | 1 |
| Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Headlamp missing |1.7.3| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| An item not tested |Manual| | 1 |
| Steering column universal joint has excessive play |2.1.5| | 1 |
| Horn not a continuous or uniform sound |1.6.2e| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Brake pedal has no servo assistance |3.3.B.2| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Inner Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Inner Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Centre Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Cab steps so insecure it is likely to cause injury (6.2.8 (a) (ii)) | 1 |
| Nearside Front Floor excessively deteriorated (6.2.4 (a) (i)) | 1 |
| Offside Front Floor excessively deteriorated (6.2.4 (a) (i)) | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Battery insecure nearside rear of two batterys (1.9.1) | 1 |
| Offside Front wheel bearing rough when rotated (2.5.A.2) | 1 |
| Brake pedal anti-slip provision missing (3.3.A.1b) | 1 |
| Nearside Headlamp not working on dipped beam (1.7.5a) | 1 |
| Offside Headlamp not working on dipped beam (1.7.5a) | 1 |
| Offside Rear fog lamp not working (1.3.2b) | 1 |
| Rear fog lamp tell tale not working (1.3.1b) | 1 |
| Offside Rear position lamp(s) not working (1.1.A.3b) | 1 |
| Offside Front Headlamp not working on dipped beam (1.7.5a) | 1 |
| Rear fog lamp tell tale missing (1.3.1b) | 1 |
| Offside Front Side repeater not working (1.4.A.2c) | 1 |
| Nearside Front Headlamp not working on main beam (1.7.5a) | 1 |
| Offside Front Headlamp not working on main beam (1.7.5a) | 1 |
| Offside Front position lamp(s) not working (1.1.A.3b) | 1 |
| Nearside Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Electrical wiring likely to touch hot or rotating parts touching back box (4.11 (a) (iii)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |