| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 17 |
| Headlamp aim out of alignment | 16 |
| Parking brake: efficiency below requirements |3.7.B.7| | 8 |
| Registration plate lamp issues | 6 |
| Offside Rear fog lamp not working |1.3.2b| | 5 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 5 |
| Horn not working |1.6.2a| | 5 |
| Brakes imbalanced across an axle | 5 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 4 |
| Exhaust system not adequately supported |7.1.1| | 3 |
| Brake hose excessively deteriorated | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Front Inner Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Stop lamp(s) light intensity significantly reduced (4.3.3 (a) (ii)) | 1 |
| Electrical wiring insecure and connectors likely to become disconnected Negative battery terminal (4.11 (a) (ii)) | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch - Subframe mount area (5.3.6 (a) (i)) | 1 |
| Offside Rear Direction indicator incorrect colour faded to white (4.4.3 (a)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Front Seat belt webbing significantly weakened (7.1.2 (b) (ii)) | 1 |
| Exhaust system insecure exhaust mountings broken |6.1.2 |a|| | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Rear Upper Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Front Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing/wheel arch area (5.3.6 (a) (i)) | 1 |
| Offside Front Exhaust system not adequately supported |7.1.1| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Battery insecure |1.9.1| | 1 |
| Brake hose has insufficient room to move | 1 |
| Front brake application uneven | 1 |
| Front brake excessively fluctuating | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Rear Stop lamp has a product on the light source so it is not visible from a reasonable distance |1.2.1d| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced out rigger near chassis (6.1.1 (c) (i)) | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Outline marker lamp light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Brake pipe excessively corroded | 1 |
| Nearside Obligatory mirror insecure |8.1.1| | 1 |
| Offside Front Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Rear fog lamp switch inoperative (4.5.3 (a)) | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering jacking point (6.1.1 (c) (ii)) | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering jacking point and inner wheel arch (6.1.1 (c) (ii)) | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings front cross member |6.1.B.2| | 1 |
| Offside Front Inner Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Offside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced chassie (6.1.1 (c) (i)) | 1 |
| Offside Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill near back of step (6.1.1 (c) (i)) | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Front Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting innefr wing at jacking point holed corroded (6.2.2 (d) (i)) | 1 |
| Central Exhaust has a major leak of exhaust gases pipe at mounting corroded and holed rest of system very rusty |6.1.2 |a|| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Rear Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Front Upper Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength jacking point (5.3.6 (a) (i)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Exhaust fumes causing a danger to health of persons on board (6.1.2 (b) (ii)) | 1 |
| Exhaust silencer likely to become detached (8.1.1 (b) (ii)) | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated (1.1.6 (d)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis behind suspension leg (5.3.6 (a) (i)) | 1 |
| Offside Front Service brake grabbing severely (1.2.1 (c)) | 1 |
| Nearside Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Offside Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |