| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 4 |
| Registration plate lamp issues | 3 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Brakes imbalanced across an axle | 2 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
| Rear brake application uneven | 2 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Suspension has inadequate clearance with the chassis |2.4.A.1a| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Upper Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Lower Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Exhaust system not adequately supported in parts rubier mounts split |7.1.1| | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Engine MIL inoperative or indicates a malfunction illuminated |8.2.2.2 |g|| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced Step (7.1.1 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill/door step mid section and rear |7.1.1 |a| |i|| | 1 |
| Nearside Front Inner Subframe mounting prescribed area excessively corroded significantly reducing structural strength sill/jacking point corroded |5.3.6 |a| |i|| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Front brake excessively fluctuating | 1 |
| Rear brake binding | 1 |
| Front brake application uneven | 1 |
| Nearside Front Electrical wiring inadequately supported |1.9.2a| | 1 |
| Nearside Front Electrical wiring damaged and bare wires exposed |1.9.2c| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working When position lights on |1.2.1b| | 1 |
| Nearside Front Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Brake pipe inadequately supported |3.6.B.1| | 1 |