| Most common failures | No# failures |
|---|
| Service brake: efficiency below requirements |3.7.B.7| | 11 |
| Brakes imbalanced across an axle | 11 |
| Parking brake: efficiency below requirements |3.7.B.7| | 8 |
| Windscreen wiper does not clear the windscreen effectively | 7 |
| Headlamp aim out of alignment | 6 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Rear parking brake recording little or no effort | 4 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 3 |
| Braking system leaking |3.6.A.1| | 3 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Front brake application uneven | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Brake pipe excessively corroded | 2 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Brake hose excessively deteriorated | 2 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Hydraulic brake cylinder leaking hydraulic fluid Brake master cylinder |3.6.A.1| | 1 |
| Nearside Rear Upper Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Rear Upper Leaf spring shackle pin locking device missing |2.4.B.3b| | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Braking system leaking |3.6.A.1| | 1 |
| Rear Braking system leaking |3.6.A.1| | 1 |
| Headlamp not working on dipped beam both |1.7.5a| | 1 |
| Offside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Front Fuel pipe leaking |7.2.3| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Fuel tank leaking p/u and drain |7.2.3| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Brake cable locking device insecure |3.5.1l| | 1 |
| Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush and rear |2.4.B.2| | 1 |
| Offside Front Leaf spring has excessive wear in a shackle pin and/or bush and rear |2.4.B.2| | 1 |
| Hand operated control valve leaking |3.2.1d| | 1 |
| Nearside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Drag link end ball joint dust cover missing |2.2.C.1c| | 1 |
| Offside Drag link end ball joint dust cover missing |2.2.C.1c| | 1 |
| Nearside Drag link end loose |2.2.B.1d| | 1 |
| Offside Drag link end loose |2.2.B.1d| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Brake pedal creeps down under servo assistance and touches the floor |3.3.C.3| | 1 |
| Nearside Front Upper Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Offside Front front brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front front brake grabbing severely |3.7.A.2b| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Nearside Outer Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Outer Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Registration plate lamp issues | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Anti-roll bar attachment bracket/mounting nut missing |2.4.G.1| | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting nut missing |2.4.G.1| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Track rod end ball joint dust cover missing |2.2.C.1c| | 1 |
| Nearside Rear Torsion bar excessive play at an end fixing |2.4.E.2| | 1 |
| Offside front brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Offside Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn king pin |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn king pin |5.3.4 |a| |i|| | 1 |
| Nearside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill |6.2.2 |d| |i|| | 1 |
| Offside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill welding |6.2.2 |d| |i|| | 1 |
| Rear Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Parking |secondary brake| on a single line braking system imbalanced across an axle Axle 1 |1.3.1 |b| |i|| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Leaf spring anchor pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Horn not working |1.6.2a| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Rear Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Steering box insecure |2.2.B.1a| | 1 |
| Parking brake lever inappropriately repaired |3.1.8| | 1 |
| Parking brake lever insecure |3.1.3b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Brake clevis joint locking device missing |3.5.1l| | 1 |