| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 12 |
| Registration plate lamp issues | 10 |
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Anti-lock braking system warning lamp indicates an ABS fault | 7 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 3 |
| Battery insecure |1.9.1| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Centre Stop lamp not working |1.2.1b| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Exhaust has a major leak of exhaust gases front flex |7.1.2| | 2 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Brake pipe excessively corroded | 2 |
| Stop lamp not working |1.2.1b| | 2 |
| brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Registration plate issues | 1 |
| Headlamp cleaning device inoperative |1.7.2| | 1 |
| Nearside Rear Headlamp levelling device inoperative control arm broken |1.7.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Rear coil spring broken |2.4.C.1a| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Rear Exhaust has a major leak of exhaust gases back box (6.1.2 (a)) | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Headlamp switch missing |1.7.1| | 1 |
| Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Offside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Position lamp switch missing |1.1.A.1| | 1 |
| Emissions not tested |7.0| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Rear Stop lamp|s| not working both sides |4.3.1 |a| |ii|| | 1 |
| Nearside Front Inner Suspension arm pin or bush excessively worn REAR BUSH |5.3.4 |a| |i|| | 1 |
| Offside Hazard warning switch inoperative |4.4.2 |a| |ii|| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Nearside Rear Seat belt buckle missing (7.1.2 (d)) | 1 |
| Offside Rear Seat belt buckle missing (7.1.2 (d)) | 1 |
| Rear Passengers seat insecure base not secure (6.2.6 (a) (ii)) | 1 |
| Central Front Exhaust has a major leak of exhaust gases downpipe flexi has had a cut and shut repair flexi which is split and blowing and is the wrong size / the rest of down pipe has also had several welding repairs and joints (6.1.2 (a)) | 1 |
| Emissions not tested due to exhaust blow (8.2.1.2 (d)) | 1 |
| Nearside Rear Headlamp levelling device inoperative self leveler snapped off reqs full unit arm looks ok (4.1.5 (a)) | 1 |
| Nearside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
| Electronic stability system warning lamp does not illuminate |3.4.1b| | 1 |
| Offside Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Hazard warning switch insecure |1.4.B.1d| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Rear brake binding | 1 |
| Nearside Front Front suspension has excessive play in a pin or bush of a lower wishbone inner bearing |2.5.B.1a| | 1 |
| Offside Front Front suspension has excessive play in a pin or bush of a lower wishbone inner bearing |2.5.B.1a| | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Nearside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear coil spring cracked |2.4.C.1a| | 1 |
| Front brake application uneven | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 1 |
| Offside Rear coil spring fractured |2.4.C.1a| | 1 |