| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 18 |
| Registration plate issues | 14 |
| Windscreen wiper does not clear the windscreen effectively | 7 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 6 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 6 |
| Rear Mechanical brake component has restricted free movement | 6 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 5 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 5 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 4 |
| Offside Stop lamp not working |1.2.1b| | 4 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Rear brake binding | 3 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Rear parking brake recording little or no effort | 3 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
| Nearside Rear Brake cable has restricted free movement |3.5.1k| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Upper Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Steering column has excessive movement up and down |2.2.2 |a|| | 1 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Parking brake operation grabbing severely |3.7.C.3b| | 1 |
| Nearside Front Lower Suspension arm pin or bush likely to become detached front arm (5.3.4 (a) (ii)) | 1 |
| Offside Front Lower Suspension arm pin or bush likely to become detached bush broken away front arm (5.3.4 (a) (ii)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Offside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear Braking system leaking HOSE TO CALIPER UNION |3.6.A.1| | 1 |
| Nearside Front Upper Suspension arm pin or bush excessively worn rear most |5.3.4 |a| |i|| | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn rear most |5.3.4 |a| |i|| | 1 |
| An item not tested |Manual| | 1 |
| Nearside Front Upper Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Headlamp levelling device obviously defective |1.7.2| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Brake pedal creeps down under servo assistance and touches the floor |3.3.C.3| | 1 |
| Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Brake hose leaking (3.6.A.1) | 1 |
| Nearside Front Front constant velocity joint gaiter split (2.5.C.1a) | 1 |
| Offside Front Shock absorbers insecurely attached Bolt loose (5.3.2 (a) (i)) | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc (2.5.C.1a) | 1 |
| Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt front |2.4.G.2| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Offside Front Front constant velocity joint is insecure |2.5.C.1b| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Outer Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Hydraulic brake calliper leaking Pipe (1.1.16 (b) (i)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Front Front position lamp|s| not working both |1.1.A.3b| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Offside Front Lower Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front coil spring fractured |2.4.C.1a| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn upper rear arm (5.3.4 (a) (i)) | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Outer Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Brake pipe excessively corroded | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 1 |
| Brakes imbalanced across an axle | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Steering linkage ball joint has excessive play rack end (2.1.3 (b) (i)) | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt insecure large retaining clip missing (2.1.3 (g) (ii)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt split (6.1.7 (g) (ii)) | 1 |
| Nearside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
| Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Nearside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Service brake grabbing severely |3.7.C.2| | 1 |
| Front passenger seat insecure |6.2.3| | 1 |
| Front passenger seat cannot be secured in the upright position. |6.2.4| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear An item not tested |Manual| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Registration plate lamp issues | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Suspension arm has excessive play in a track control arm inner bush |2.5.B.2b| | 1 |
| Nearside Front brake caliper leaking |3.6.A.1| | 1 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Lower Stub axle cracked |2.5.A.5a| | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |