| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 11 |
| Parking brake: efficiency below requirements |3.7.B.7| | 11 |
| Rear parking brake recording little or no effort | 7 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 6 |
| Registration plate issues | 6 |
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Rear brake binding | 5 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 5 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 5 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Windscreen washer not working | 3 |
| Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Registration plate lamp issues | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Outer Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Rear brake application uneven | 2 |
| Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front coil spring incomplete |2.4.C.1a| | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Front brake application uneven | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Outer Front constant velocity joint gaiter split (2.5.C.1a) | 1 |
| Offside Rear Brake cable has restricted free movement (3.5.1k) | 1 |
| Parking brake: efficiency below requirements (3.7.C.1b) | 1 |
| Nearside Front Lower Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement (2.4.G.2) | 1 |
| Offside Front Lower Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement (2.4.G.2) | 1 |
| Offside Front Track rod end deformed and unserviceable (2.2.C.1d) | 1 |
| Nearside Front constant velocity joint gaiter split (2.5.C.1a) | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Rear Inner Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Brake performance not tested both front brakes excessively binding (1.2.1 (g)) | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Rear Brake lever has restricted free movement parking brake |3.5.1k| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Suspension arm pin or bush excessively worn upper rear arm inner bush |5.3.4 |a| |i|| | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt insecure /small split |6.1.7 |g| |ii|| | 1 |
| Nearside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Offside Rear brake caliper leaking |3.6.A.1| | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp switch not operating in accordance with the requirements (4.5.3 (a)) | 1 |
| Offside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside Rear Brake hose leaking |3.6.A.1| | 1 |
| Nearside Front Power steering pipe|s| or hose|s| excessively corroded |2.3.2| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear Headlamp levelling device obviously defective |1.7.2| | 1 |
| Front Service brake juddering severely |3.7.C.2| | 1 |
| Front Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Brake linkage has restricted free movement |3.5.1k| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Rear Brake lining|s| less than 1.5 mm thick |3.5.1g| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Track rod end ball pin shank loose |2.2.B.1c| | 1 |
| Brakes imbalanced across an axle | 1 |
| Nearside Inner Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Outer Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn rear arm (5.3.4 (a) (i)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Offside Front Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Boot lid cannot be secured in the closed position (6.2.1 (e)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Front Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Offside Other passenger door cannot be opened from outside the vehicle 2nd door (6.2.3 (a)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp insecure (4.1.1 (c)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Upper Suspension arm pin or bush excessively worn both top (5.3.4 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |