| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 26 |
| Anti-lock braking system warning lamp indicates an ABS fault | 20 |
| Rear parking brake recording little or no effort | 18 |
| Headlamp aim out of alignment | 16 |
| Windscreen wiper does not clear the windscreen effectively | 16 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 14 |
| Brake hose excessively deteriorated | 12 |
| Offside Rear fog lamp not working |1.3.2b| | 11 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 10 |
| Parking brake lever has no reserve travel |3.1.6b| | 9 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 8 |
| Registration plate lamp issues | 8 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 7 |
| Registration plate issues | 7 |
| Windscreen washer not working | 6 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 6 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 5 |
| Windscreen has damage | 5 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Rear brake binding | 5 |
| Front brake disc in such a condition that it is seriously weakened | 5 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 4 |
| Offside Stop lamp not working |1.2.1b| | 4 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 4 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 3 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
| Brakes imbalanced across an axle | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Service brake: efficiency below requirements |3.7.C.1a| | 2 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Brake lever has restricted free movement |3.5.1k| | 2 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 2 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 2 |
| Stop lamp remains on when the brakes are released | 2 |
| Offside Front brake disc excessively scored |3.5.1h| | 2 |
| Fuel cap/sealing device missing |7.2.4a| | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Front coil spring broken |2.4.C.1a| | 2 |
| Horn not working |1.6.2a| | 2 |
| Nearside Rear Seat belt retracting mechanism defective Passed ref Inspection manual 4.3.1 (7.1.2 (e)) | 2 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt Insecure (6.1.7 (g) (ii)) | 2 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Brake hose excessively damaged |3.6.B.4d| | 1 |
| Offside Rear Brake hose excessively damaged |3.6.B.4d| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Offside Front Lower coil spring fractured |2.4.C.1a| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Nearside Front Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
| Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Brake lever has restricted free movement |3.5.1k| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front brake disc excessively scored |3.5.1h| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Steering damper leaking oil |2.2.C.1f| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Brake hose damaged | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint rear arm |2.4.G.2| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Rear fog lamp has less than 50% of the light sources illuminating |1.3.2b| | 1 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Nearside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush lower rear suspension arm |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush lower rear arm |2.4.G.2| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp aim beam image kick up to the offside both |1.8| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Emissions not tested |7.0| | 1 |
| Offside Front Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Inner Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Inner Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Electronic stability control switch not functioning correctly (7.12 (d)) | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Emissions not tested vehicle is missfireing affeting emissions( hydrocarbons ) (8.2.1.2 (d)) | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Brake pipe excessively corroded | 1 |
| Nearside Front Suspension arm likely to become detached (5.3.3 (a) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Front Direction indicator incorrect colour both gone white |1.4.A.2f| | 1 |
| Nearside Front Valve stem seriously damaged |5.2.3 |j|| | 1 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Upper Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
| Nearside Front Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear Fuel system component leaking |7.2.3| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front Direction indicator missing |1.4.A.2b| | 1 |
| Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Parking brake operation is causing the vehicle to swerve to the nearside |3.7.C.3a| | 1 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Nearside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Track rod end damaged and unserviceable |2.2.C.1d| | 1 |
| Exhaust mounting missing |7.1.1b| | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Upper Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Exhaust catalytic converter missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
| Offside Exhaust catalytic converter missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |