| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 39 |
| Brake hose excessively deteriorated | 31 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 26 |
| Registration plate issues | 24 |
| Registration plate lamp issues | 22 |
| Windscreen wiper does not clear the windscreen effectively | 19 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 14 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 10 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 9 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 8 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 8 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 8 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 7 |
| Brake hose damaged | 7 |
| Rear brake binding | 7 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Windscreen has damage | 7 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 5 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 5 |
| Nearside Stop lamp not working |1.2.1b| | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Brakes imbalanced across an axle | 5 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 4 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 4 |
| Rear fog lamp not working |1.3.2b| | 4 |
| Rear brake disc in such a condition that it is seriously weakened | 4 |
| Brake pipe excessively corroded | 4 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 4 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 4 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Nearside Front Brake pipe seriously damaged |found during steering lock to lock check| |2.2.D.2b| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Service brake: efficiency below requirements |3.7.C.1a| | 3 |
| Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Front Brake hose excessively damaged |3.6.B.4d| | 2 |
| Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Brake performance not tested |3.7.A.1| | 2 |
| Fuel system component insecure |7.2.1| | 2 |
| Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
| Offside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Fuel system component leaking |7.2.3| | 2 |
| Mechanical brake component has restricted free movement | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn rear arm (5.3.4 (a) (i)) | 1 |
| Electrical wiring damaged and bare wires exposed |1.9.2c| | 1 |
| Nearside Rear Passenger`s seat insecure |6.2.A.1| | 1 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Trailer electrical socket damaged so that lead cannot be securely connected |1.9.3b| | 1 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Exhaust catalytic converter missing where one was fitted as standard |8.2.1.1 |a|| | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Bootlid cannot be secured in the closed position |6.4.1| | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt boot split (6.1.7 (g) (ii)) | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt boot split (6.1.7 (g) (ii)) | 1 |
| Front Brake disc significantly and obviously worn inner surfaces (1.1.14 (a) (i)) | 1 |
| Nearside Front Headlamp levelling device inoperative levelling motor arm snapped (4.1.5 (a)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn front arm (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn front arm (5.3.4 (a) (i)) | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Front Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Nearside Front Windscreen wiper blade missing |8.2.2| | 1 |
| Offside Front Windscreen wiper blade missing |8.2.2| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Track rod end loose |2.2.B.1d| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt rear link |2.4.G.2| | 1 |
| Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement front link |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement rear link |2.4.G.2| | 1 |
| Offside Exhaust has a major leak of exhaust gases back box welding |7.1.2| | 1 |
| Offside Rear Brake hose leaking |3.6.A.1| | 1 |
| Offside Rear Road wheel cracked |4.2.A.1a| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Front Service brake grabbing severely |1.2.1 |c|| | 1 |
| Offside Front Service brake grabbing severely |1.2.1 |c|| | 1 |
| Brake performance not tested |1.2.1 |g|| | 1 |
| Nearside Front Road wheel badly damaged |4.2.A.1a| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Front drive shaft coupling flexible rubber or fabric coupling unit breaking up |2.5.C.1d| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Offside Outer Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Offside Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Position lamp light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
| Offside Rear Stop lamp(s) light intensity significantly reduced (4.3.3 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits due to exhaust leak (8.2.1.2 (c)) | 1 |
| Offside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Inner Front Road wheel cracked |4.2.A.1a| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Front Brake performance not tested |3.7.A.1| | 1 |
| Rear Brake performance not tested |3.7.A.1| | 1 |
| Nearside Front Upper Suspension arm insecure |2.4.G.1| | 1 |
| Nearside Front Upper Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Outer Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Upper Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Brake pipe excessively chafed |3.6.B.2c| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Inner Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Brake vacuum build up too slow |3.3.E.6| | 1 |
| Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 1 |
| Nearside Side repeater insecure |1.4.A.2b| | 1 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Emissions not tested |7.0| | 1 |
| Electronic stability system warning lamp does not illuminate |3.4.1b| | 1 |
| Offside Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Lower Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside All position lamps not working |1.1.A.3b| | 1 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn Both Top Arms (5.3.4 (a) (i)) | 1 |
| Nearside Front Upper Suspension arm pin or bush excessively worn Top Rear Arm (5.3.4 (a) (i)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Headlamp has a product on the light source so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Headlamp has a product on the light source so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Rear coil spring broken |2.4.C.1a| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn front arm |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn front arm |5.3.4 |a| |i|| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Front Body has a sharp edge caused by damage bumper |6.1.C.1| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Nearside Outer Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Front Headlamp cleaning device inoperative |1.7.2| | 1 |
| Front Headlamp levelling device obviously defective |1.7.2| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Rear Shock absorber casing corroded externally so the unit does not function |2.7.2a| | 1 |
| Offside Rear Shock absorber casing corroded externally so the unit does not function |2.7.2a| | 1 |
| Front Inner Brake disc significantly and obviously worn n/s o/s (1.1.14 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt front (5.3.4 (b) (ii)) | 1 |
| Offside Outer Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Outer Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Trailing arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |