| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 50 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 22 |
| Registration plate lamp issues | 19 |
| Registration plate issues | 17 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 15 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 13 |
| Offside Rear coil spring broken |2.4.C.1a| | 12 |
| Windscreen wiper does not clear the windscreen effectively | 12 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 10 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 9 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 8 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 7 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 7 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 7 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 6 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 6 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 4 |
| Exhaust catalytic converter missing where one was fitted as standard (8.2.1.1 (a)) | 4 |
| Nearside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 4 |
| Emissions not tested (8.2.1.2 (d)) | 3 |
| Nearside Rear coil spring broken |2.4.C.1a| | 3 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Offside Side repeater not working |1.4.A.2c| | 3 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 3 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 3 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 3 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction (3.1 (a) (ii)) | 2 |
| Exhaust carbon monoxide content at idle exceeds default limits |8.2.1.2 |b|| | 2 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Emissions unable to be completed (8.2.2.2 (e)) | 2 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Central Rear Seat belt retracting mechanism defective (7.1.2 (e)) | 2 |
| Offside Rear Direction indicator incorrect colour |4.4.3 |a|| | 2 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 2 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Windscreen washer not working | 2 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Rear Shock absorbers has a serious fluid leak | 2 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Windscreen damaged and affecting the drivers view of the road Crack More Than 40mm Inside Swept Area (3.2 (a) (ii)) | 1 |
| Nearside Rear All direction indicators incorrect colour (4.4.3 (a)) | 1 |
| Offside Rear All direction indicators incorrect colour (4.4.3 (a)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits no cat (8.2.1.2 (c)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits no cat (8.2.1.2 (b)) | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Front Road wheel fractured inner |chalked| |4.2.B.1a| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturer`s specified limits |8.2.1.2 |b|| | 1 |
| Exhaust catalytic converter missing where one was fitted as standard |8.2.1.1 |a|| | 1 |
| Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Brake performance not tested Due to n/s/f cord exposed vehicle 4x4 need decelometer test. (1.2.1 (g)) | 1 |
| Nearside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Front Outer Prop shaft joint constant velocity boot no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Rear Service brake excessively binding un able to check wheel bearing (1.2.1 (f)) | 1 |
| Nearside Rear Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Rear Service brake grabbing severely |1.2.1 |c|| | 1 |
| Nearside Body insecure and dangerous to other road users wing mirror |6.1.B.1b| | 1 |
| Nearside Front Inner Road wheel fractured (5.2.2 (a)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Rear Hydraulic brake calliper leaking |1.1.16 |b| |i|| | 1 |
| Offside Rear Hydraulic brake calliper leaking |1.1.16 |b| |i|| | 1 |
| Front Headlamp cleaning device for LED or HID headlamp inoperative low fluids (4.1.6 (a) (ii)) | 1 |
| Offside Front Anti-roll bar ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Rear Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Emissions not tested due to no catalytic converter (8.2.1.2 (d)) | 1 |
| Front Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction (3.1 (a) (ii)) | 1 |
| Headlamp cleaning device inoperative |1.7.2| | 1 |
| All position lamps not working front and rear sidelights not working |1.1.A.3b| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Road wheel fractured (5.2.2 (a)) | 1 |
| Nearside Rear Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Nearside Rear Lower coil spring broken |2.4.C.1a| | 1 |
| Offside Rear Lower coil spring broken |2.4.C.1a| | 1 |
| Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Side repeater light intensity significantly reduced (4.4.3 (a)) | 1 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt split (6.1.7 (g) (ii)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Rear Brake disc significantly and obviously worn both (1.1.14 (a) (i)) | 1 |
| Offside Rear brake caliper leaking |3.6.A.1| | 1 |
| Offside Front Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Nearside Rear Brake pipe connection leaking on a hydraulic braking system |1.1.11 |b| |ii|| | 1 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Nearside Front Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Front coil spring broken |2.4.C.1a| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Drivers seat insecure (6.2.5 (a) (ii)) | 1 |
| Nearside Side repeater lens defective such that the emitted light is adversely affected intermittently stops working (4.4.1 (b) (ii)) | 1 |
| Fuel system component leaking filter area (6.1.3 (b) (i)) | 1 |
| Nearside Front Seat belt missing (7.1.2 (a)) | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Engine MIL inoperative or indicates a malfunction engine management light on (8.2.1.2 (h)) | 1 |
| Offside Rear Direction indicator likely to become detached (4.4.1 (c) (ii)) | 1 |
| Nearside Front Headlamp insecure |4.1.1 |c|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Nearside Rear Outer Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Central Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Offside Rear Brake pipe leaking on a hydraulic braking system flexi to caliper (1.1.11 (b) (ii)) | 1 |
| Coil spring fractured or broken nearside and offside rear |5.3.1 |b| |i|| | 1 |
| Offside Rear Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Front Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Nearside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Rear Emissions oxygen sensor obviously defective lambda sensor broken (8.2.1.1 (a)) | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Braking system leaking Bleed nipple leaking |3.6.A.1| | 1 |
| Brake performance not tested Due to leak |3.7.A.1| | 1 |
| Electronic power steering warning lamp indicates a failure in the system |2.3.8| | 1 |
| Offside Rear Service brake grabbing severely (1.2.1 (c)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Outer Position lamp light intensity significantly reduced |4.2.3 |a| |ii|| | 1 |
| Offside Rear Inner Position lamp not working |4.2.1 |a|| | 1 |
| Headlamp cleaning device for LED or HID headlamp inoperative |4.1.6 |a| |ii|| | 1 |
| Central Front Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits cat missing (8.2.1.2 (a)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Nearside Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Nearside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Offside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Windscreen in such a condition that visibility through swept area is seriously affected tinted sun visor in swept area (3.2 (c) (ii)) | 1 |
| Nearside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Exhaust system insecure centre sleeve clamp broken (6.1.2 (a)) | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition (8.1.1 (a)) | 1 |
| Nearside Front Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Road wheel more than one fixing missing one on each wheel (5.2.1 (a) (ii)) | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Emissions unable to be completed unable to rev engine (8.2.1.2 (d)) | 1 |
| Exhaust catalytic converter obviously modified (8.2.1.1 (a)) | 1 |
| Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Side repeater light intensity significantly reduced (4.4.3 (a)) | 1 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Front Exhaust silencer insecure (8.1.1 (b) (i)) | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Windscreen has damage | 1 |