Most common failures | No# failures |
---|
Headlamp aim out of alignment | 28 |
Windscreen wiper does not clear the windscreen effectively | 21 |
Brake hose excessively deteriorated | 20 |
Brakes imbalanced across an axle | 13 |
Registration plate lamp issues | 12 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 11 |
Brake pipe excessively corroded | 10 |
Parking brake: efficiency below requirements |3.7.B.7| | 10 |
Exhaust has a major leak of exhaust gases |7.1.2| | 8 |
Rear parking brake recording little or no effort | 8 |
Rear brake binding | 7 |
Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
Service brake: efficiency below requirements |3.7.B.7| | 6 |
Horn not working |1.6.2a| | 6 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 5 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 5 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Offside Front constant velocity joint gaiter split |2.5.C.1a| | 4 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 4 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 4 |
Registration plate issues | 4 |
Offside front brake binding |3.7.B.1| | 4 |
Front brake disc in such a condition that it is seriously weakened | 4 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 4 |
Rear brake application uneven | 3 |
Nearside Stop lamp not working |1.2.1b| | 3 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Nearside Rear wheel bearing has excessive play |2.6.2| | 3 |
Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Centre Exhaust system not adequately supported |7.1.1| | 3 |
Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 3 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
Offside Rear fog lamp not working |1.3.2b| | 3 |
Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
Fuel pipe leaking |7.2.3| | 3 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Brake performance not tested |3.7.A.1| | 2 |
Offside Brake cable has wires broken and is significantly weakened |3.5.1b| | 2 |
Offside Front front brake binding |3.7.B.1| | 2 |
Brake load sensing valve linkage obviously incorrectly adjusted |3.6.E.3| | 2 |
Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
Hazard warning switch faulty |1.4.B.1d| | 2 |
Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Nearside front brake binding |3.7.B.1| | 2 |
Offside Front Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Offside Front coil spring broken |2.4.C.1a| | 2 |
Offside Front Steering system excessively tight |2.2.D.1| | 2 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Rear Rear fog lamp not working |1.3.2b| | 2 |
Offside Headlamp not working on main beam |1.7.5a| | 2 |
Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 2 |
Front brake application uneven | 2 |
Rear Exhaust system not adequately supported |7.1.1| | 2 |
Nearside Rear rear brake grabbing severely |3.7.A.5b| | 2 |
Windscreen washer not working | 2 |
Offside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 2 |
Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Brake fluid warning lamp illuminated |3.6.G.2| | 2 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Rear Rear wheel bearing has excessive play |2.6.2| | 2 |
Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
Windscreen wiper blade insecure | 2 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
Offside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front drive shaft coupling flexible rubber or fabric coupling unit breaking up |2.5.C.1d| | 1 |
Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Exhaust emissions carbon monoxide content excessive test carried out twice, unable to pass. |7.3.B.1a| | 1 |
Brake performance not tested vehicle cut out after emissions will not start again. |3.7.A.1| | 1 |
Rear Fuel pipe excessively chafed |7.2.2| | 1 |
Parking brake lever has excessive side play in the pivot and may disengage |3.1.4a| | 1 |
Subframe mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Front Fuel pipe leaking |7.2.3| | 1 |
Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Brake pedal does not operate a brake fitted to each wheel |3.3.A.3| | 1 |
Brake pedal creeps down under servo assistance and touches the floor |3.3.C.3| | 1 |
Nearside Front Brake hose leaking |3.6.A.1| | 1 |
Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Windscreen has damage | 1 |
Centre Obligatory mirror missing |8.1.1| | 1 |
Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Outer Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Windscreen wiper blade deteriorated |8.2.2| | 1 |
Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
Rear wheel bearing has excessive play |2.6.2| | 1 |
Nearside Direction indicator not working |1.4.A.2c| | 1 |
Nearside Front Direction indicator missing |1.4.A.2b| | 1 |
Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
Offside front brake recording little or no effort |3.7.B.5a| | 1 |
Rear Brake valve leaking |3.6.A.1| | 1 |
Offside Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
Nearside rear brake recording little or no effort and slow to react |3.7.B.5a| | 1 |
Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement rear bush |2.4.G.2| | 1 |
Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering spring hanger (6.1.1 (c) (ii)) | 1 |
Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering (6.1.1 (c) (ii)) | 1 |
Offside Front Road wheel distorted |4.2.A.1a| | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
Direction indicators not working |1.4.A.2c| | 1 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front coil spring incomplete |2.4.C.1a| | 1 |
Offside Front Subframe mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Rear Exhaust mounting missing |7.1.1b| | 1 |
Rear Exhaust has a major leak of exhaust gases back box and mid section join. |7.1.2| | 1 |
Emissions not tested due to exhaust leak. |7.3.A.1| | 1 |
Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Front Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Offside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Front Direction indicator not working |1.4.A.2c| | 1 |
Rear Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
Front Statutory seat belt of the wrong type. |5.1.1| | 1 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Nearside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Headlamp aim not tested |1.8.A.1c| | 1 |
Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt small end |6.1.7 |g| |ii|| | 1 |
Rear Rear fog lamp tell tale not working |1.3.1b| | 1 |
Battery insecure |1.9.1| | 1 |
Rear Fuel system component insecure |7.2.1| | 1 |
Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Offside Steering component mounting prescribed area so damaged that control of the vehicle is likely to be adversely affected mcphearson strut/ track rod end mounting point |2.1.2 |e| |ii|| | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill |5.3.6 |a| |i|| | 1 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
rear brakes release unevenly |3.7.B.4| | 1 |
Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill (5.3.6 (a) (i)) | 1 |
Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill (5.3.6 (a) (i)) | 1 |
Nearside Front Upper Macpherson strut pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Upper Macpherson strut pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Offside Rear brake disc excessively scored |3.5.1h| | 1 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Front front brake grabbing severely |3.7.A.2b| | 1 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Rear Body has a projection caused by corrosion |6.1.C.1| | 1 |
Nearside Obligatory mirror does not provide a view to the rear |8.1.2b| | 1 |
Offside Obligatory mirror does not provide a view to the rear |8.1.2b| | 1 |
Brake lever has restricted free movement |3.5.1k| | 1 |
Offside rear brake grabbing severely |3.7.A.5b| | 1 |
Offside Front Position lamp not working |4.2.1 |a|| | 1 |
Offside Front Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
Nearside rear brake recording little or no effort foot |3.7.B.5a| | 1 |
Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Headlamp insecure |1.7.3| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Braking system leaking master |3.6.A.1| | 1 |
Offside Stop lamp not working |1.2.1b| | 1 |
Rear brake disc excessively pitted |3.5.1h| | 1 |
Offside Front brake disc excessively pitted |3.5.1h| | 1 |
Nearside Rear Fuel system component insecure |7.2.1| | 1 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Driver`s seat insecure |6.2.A.1| | 1 |
Offside Rear Direction indicator not working |4.4.1 |a| |ii|| | 1 |
Offside Rear Braking system leaking |3.6.A.1| | 1 |
Offside Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
Nearside Side repeater not working |1.4.A.2c| | 1 |
Offside Side repeater not working |1.4.A.2c| | 1 |
Horn not working (7.7 (a) (ii)) | 1 |
Offside Rear Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Rear fog lamp not working |1.3.2b| | 1 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Offside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
Nearside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Rear Fuel pipe leaking |7.2.3| | 1 |
Nearside coil spring fractured |2.4.C.1a| | 1 |
Offside Rear coil spring fractured |2.4.C.1a| | 1 |
Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Nearside Front Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Front Direction indicator missing lens missing/sharp edges (4.4.1 (a) (ii)) | 1 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Fuel system component leaking Fuel Filter is leaking (6.1.3 (b) (i)) | 1 |
Offside Rear Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
Offside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
Offside Front Brake hose leaking |3.6.A.1| | 1 |
Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
Centre Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Inner Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Inner Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Outer Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Outer Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear All position lamps adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Offside Front Anti-roll bar linkage insecure and impairing directional stability (5.3.3 (a) (ii)) | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Front Direction indicator incomplete |1.5.A1b| | 1 |
Nearside Front Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
Direction indicators not in good working order |function impaired| |1.5.A1b| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Offside Front Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |