| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 168 |
| Brake hose excessively deteriorated | 124 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 53 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 52 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 49 |
| Registration plate lamp issues | 45 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 44 |
| Brake pipe excessively corroded | 35 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 35 |
| Windscreen wiper does not clear the windscreen effectively | 35 |
| Rear fog lamp not working |1.3.2b| | 34 |
| Offside Rear fog lamp not working |1.3.2b| | 33 |
| Parking brake: efficiency below requirements |3.7.B.7| | 33 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 29 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 29 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 29 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 28 |
| Rear brake disc in such a condition that it is seriously weakened | 28 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 27 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 25 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 25 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 23 |
| Registration plate issues | 22 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 18 |
| Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 17 |
| Rear parking brake recording little or no effort | 17 |
| Front brake disc in such a condition that it is seriously weakened | 16 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 15 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 15 |
| Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 15 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 14 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 14 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 14 |
| Anti-lock braking system warning lamp indicates an ABS fault | 14 |
| Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 13 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 13 |
| Rear brake binding | 13 |
| Brakes imbalanced across an axle | 12 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 12 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 11 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 11 |
| Offside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 11 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 10 |
| Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 10 |
| Offside Stop lamp not working |1.2.1b| | 10 |
| Nearside Stop lamp not working |1.2.1b| | 10 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 10 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 9 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 9 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 9 |
| Offside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 8 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 8 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 8 |
| Nearside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 8 |
| Parking brake lever has no reserve travel |3.1.6b| | 8 |
| Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 8 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 7 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 7 |
| Offside Side repeater not working |1.4.A.2c| | 7 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 7 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 7 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 7 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 7 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 7 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 7 |
| Brake hose damaged | 7 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 7 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 7 |
| Rear Rear fog lamp not working |1.3.2b| | 7 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 6 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 6 |
| Offside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 6 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 6 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 6 |
| Rear Mechanical brake component has restricted free movement | 6 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 6 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 6 |
| Windscreen washer not working | 6 |
| Service brake: efficiency below requirements |3.7.B.7| | 6 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 6 |
| Nearside Front Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 6 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 6 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 6 |
| Centre Stop lamp not working |1.2.1b| | 5 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 5 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 5 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 5 |
| Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 5 |
| Nearside Rear Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 5 |
| Fuel system component leaking |7.2.3| | 5 |
| Nearside Rear Stop lamp not working |1.2.1b| | 5 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 5 |
| Driver`s airbag obviously defective |5.4.1| | 5 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 5 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 5 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 5 |
| Front brake excessively fluctuating | 5 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 4 |
| Offside Front Position lamp not working |4.2.1 |a|| | 4 |
| Nearside Side repeater not working |1.4.A.2c| | 4 |
| Nearside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 4 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 4 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 4 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 4 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 4 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 4 |
| Nearside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 4 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 4 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 4 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 4 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 4 |
| Nearside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 4 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Engine MIL inoperative or indicates a malfunction |8.2.2.2 |g|| | 4 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 4 |