Most common failures | No# failures |
---|
Brake hose excessively deteriorated | 25 |
Headlamp aim out of alignment | 17 |
Rear fog lamp not working |1.3.2b| | 9 |
Registration plate lamp issues | 8 |
Offside Rear fog lamp not working |1.3.2b| | 7 |
Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 7 |
Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 6 |
Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 6 |
Brake pipe excessively corroded | 5 |
Registration plate issues | 5 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 5 |
Brakes imbalanced across an axle | 5 |
Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
Rear brake binding | 4 |
Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 4 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
Offside Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
Offside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
Nearside Front Air suspension unit totally deflated |2.4.D.1a| | 2 |
Nearside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 2 |
Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
Nearside Front Brake hose damaged and likely to fail (1.1.12 (a)) | 2 |
Air suspension has no suspension movement |2.4.D.5| | 2 |
Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 2 |
Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
Offside Front Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
Parking brake: efficiency below requirements |3.7.B.7| | 2 |
Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Offside Rear brake caliper leaking |3.6.A.1| | 2 |
Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
Front brake disc in such a condition that it is seriously weakened | 2 |
Front brake application uneven | 2 |
Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
Offside Front Lower Suspension arm pin or bush excessively worn Rear inner (5.3.4 (a) (i)) | 1 |
Offside Front Lower Suspension arm pin or bush excessively worn Front inner (5.3.4 (a) (i)) | 1 |
Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
Nearside Front Outer Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
Offside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Lower Suspension arm pin or bush excessively worn wish bone inner rear bush |5.3.4 |a| |i|| | 1 |
Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
Nearside Rear Stop lamp(s) light intensity significantly reduced (4.3.3 (a) (ii)) | 1 |
Nearside Front Anti-roll bar linkage likely to become detached (5.3.3 (a) (ii)) | 1 |
Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
Nearside Front Fuel system component leaking |7.2.3| | 1 |
Fluid leaking continuously posing a serious risk to road safety diesel leak |injector leak off pipes| |8.4.1 |a| |ii|| | 1 |
Offside Rear Brake hose connection leaking on a hydraulic braking system at caliper banjo |1.1.12 |c| |ii|| | 1 |
Offside Front Upper Suspension arm pin or bush excessively worn FRONT (5.3.4 (a) (i)) | 1 |
Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
Rear fog lamp tell tale not working |1.3.1b| | 1 |
Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
Front brake excessively fluctuating | 1 |
Offside Front Position lamp not working |4.2.1 |a|| | 1 |
Front Headlamp aim projected beam image is obviously incorrect BOTH (4.1.2 (c)) | 1 |
Nearside Front Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Front Direction indicator incorrect colour |4.4.3 |a|| | 1 |
Exhaust emissions exceed manufacturer`s specified limit |8.2.2.2 |a|| | 1 |
Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc Outer. |2.5.C.1a| | 1 |
Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
Front Air suspension has no suspension movement |2.4.D.5| | 1 |
Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt both sides rear most arm |2.4.G.2| | 1 |
Offside Front Anti-roll bar linkage has excessive play in a pin/bush broken |2.4.G.2| | 1 |
Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
Offside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
Nearside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
Offside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
Service brake: efficiency below requirements |3.7.B.7| | 1 |
Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
Nearside Rear Road wheel fractured |4.2.B.1a| | 1 |
Offside Front Suspension arm attachment bracket inappropriately repaired rear lower arm bolt and nut not upto nilock |2.4.A.2| | 1 |
Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Parking brake lever has no reserve travel |3.1.6b| | 1 |
Nearside Rear brake caliper leaking |3.6.A.1| | 1 |
Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Headlamp aim projected beam image is obviously incorrect both nearside and offside aim affected by lense (4.1.2 (c)) | 1 |
Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Front Upper Suspension arm ball joint excessively worn front arm (5.3.4 (a) (i)) | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Ball joint has excessive play rack end |2.2.B.1f| | 1 |
Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
Offside Front Upper Suspension arm pin or bush excessively worn bush excessivley worn on the back arm |5.3.4 |a| |i|| | 1 |
Nearside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Front brake disc excessively scored |3.5.1h| | 1 |
Fuel system component leaking excessively or a risk of fire at engine |6.1.3 |b| |ii|| | 1 |
Nearside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
Offside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
Offside Front All position lamps not working |1.1.A.3b| | 1 |
Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Upper Suspension arm ball joint excessively worn rear arm (5.3.4 (a) (i)) | 1 |
Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
Fuel tank leaking (6.1.3 (b) (i)) | 1 |
Drivers door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
Nearside Front Lower Suspension arm ball joint excessively worn rear (5.3.4 (a) (i)) | 1 |
Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Nearside Front Lower Suspension arm has excessive play in a pin/bush rear |2.4.G.2| | 1 |
Offside Front Lower Suspension arm has excessive play in a pin/bush rear |2.4.G.2| | 1 |
Offside Rear rear brake excessively fluctuating |3.7.B.3| | 1 |
Nearside Headlamp light intensity severely reduced |4.1.4 |a|| | 1 |
Offside Headlamp light intensity severely reduced |4.1.4 |a|| | 1 |
Offside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
Rear brake disc in such a condition that it is seriously weakened | 1 |
Driver`s door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Nearside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Upper Bonded suspension unit deteriorated and cannot function as intended |2.4.F.3| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Headlamp insecure |1.7.3| | 1 |
Offside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
Nearside Front Upper Suspension arm ball joint likely to become detached Rear arm (5.3.4 (a) (ii)) | 1 |
Windscreen washer not working | 1 |
Nearside Front Lower Suspension arm pin or bush excessively worn Rear bush (5.3.4 (a) (i)) | 1 |
Offside Front Lower Suspension arm pin or bush excessively worn Rear bush (5.3.4 (a) (i)) | 1 |
Trailer electrical socket |13 pin| not operating the trailer lamps as intended |1.9.4| | 1 |
Nearside Front Brake hose excessively damaged |1.1.12 |b| |ii|| | 1 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Nearside Side repeater not working |1.4.A.2c| | 1 |
Driver`s airbag obviously defective |5.4.1| | 1 |
Windscreen wiper does not clear the windscreen effectively | 1 |
Nearside Front constant velocity joint is insecure |2.5.C.1b| | 1 |
Offside Rear Brake lever has restricted free movement |3.5.1k| | 1 |
Nearside Rear Air suspension unit leaking |2.4.D.2| | 1 |
Nearside Outer Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Nearside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Front Fuel system component leaking |7.2.3| | 1 |
Nearside engine mounting bracket insecure and likely to fail bolts loose |6.1.D.1b| | 1 |
Offside Front All position lamps have less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
Nearside Front Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Front Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt front of |2.4.G.2| | 1 |
Nearside Front Front passenger door likely to open inadvertently or not remain closed |6.2.3 |b| |ii|| | 1 |
Nearside Front Fuel system component leaking excessively or a risk of fire |6.1.3 |b| |ii|| | 1 |
Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt insecure |6.1.7 |g| |ii|| | 1 |
Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt rear |5.3.4 |b| |ii|| | 1 |
Brake performance not tested |1.2.1 |g|| | 1 |
Emissions not tested |8.2.2.2 |e|| | 1 |
Exhaust emissions exceed level of metered smoke for a non-turbo charged engine (8.2.2.2 (b)) | 1 |
Direction indicators adversely affected by the operation of another lamp when headlights turned on |1.4.A.2h| | 1 |
Offside Stop lamp not working |1.2.1b| | 1 |
Undertray likely to become detached |6.2.1 |a| |ii|| | 1 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Front Brake hose damaged and likely to fail (1.1.12 (a)) | 1 |
Central Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Rear Mechanical brake component has restricted free movement | 1 |