| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 40 |
| Windscreen wiper does not clear the windscreen effectively | 19 |
| Registration plate lamp issues | 19 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 16 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 15 |
| Brake hose excessively deteriorated | 13 |
| Offside Rear fog lamp not working |1.3.2b| | 11 |
| Rear brake binding | 10 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 10 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 10 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 10 |
| Offside front brake binding |3.7.B.1| | 8 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 8 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 7 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 7 |
| Registration plate issues | 7 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 7 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 6 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 6 |
| Nearside front brake binding |3.7.B.1| | 6 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 5 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 5 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 5 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 5 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 5 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 5 |
| Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 5 |
| Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 4 |
| Brake pipe excessively corroded | 4 |
| Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 4 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Front Air suspension has no suspension movement |2.4.D.5| | 4 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 4 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 4 |
| Rear parking brake recording little or no effort | 4 |
| Front brake disc in such a condition that it is seriously weakened | 4 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 3 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Outer Front Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
| Windscreen has damage | 3 |
| Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Brakes imbalanced across an axle | 3 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Nearside Front Service brake excessively binding |1.2.1 |f|| | 2 |
| Offside Front Service brake excessively binding |1.2.1 |f|| | 2 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front brake disc excessively pitted |3.5.1h| | 2 |
| Nearside Headlamp insecure |1.7.3| | 2 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
| Nearside Rear Air suspension has no suspension movement |2.4.D.5| | 2 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
| Offside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Front front brake binding |3.7.B.1| | 2 |
| Front brake disc excessively pitted |3.5.1h| | 2 |
| Brake performance not tested |3.7.A.1| | 2 |
| Nearside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Rear brake disc excessively scored |3.5.1h| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Rear Brake pipe connection leaking on a hydraulic braking system connection to fexible hose |1.1.11 |b| |ii|| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Rear Fuel hose leaking (6.1.3 (b) (i)) | 1 |
| Nearside Hazard warning lamps inoperative |4.4.1 |e|| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 1 |
| Nearside Front front brake grabbing severely |3.7.A.2b| | 1 |
| Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement front o/s n/s |2.4.G.2| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Track rod end ball pin shank loose |2.2.B.1c| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| An item not tested |Manual| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Front Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
| Rear Air suspension has no suspension movement |2.4.D.5| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Front brake disc has restricted free movement |3.5.1j| | 1 |
| Windscreen wiper not operating automatically when switched on both |8.2.1b| | 1 |
| front brake binding 2 front |3.7.B.1| | 1 |
| Offside Outer Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement rear |2.4.G.2| | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Position lamp light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
| Emissions not tested due to exhaust blow (8.2.1.2 (d)) | 1 |
| Nearside Front Exhaust has a major leak of exhaust gases flexi (6.1.2 (a)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn rear (5.3.4 (a) (i)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect lens deteriorated (4.1.2 (c)) | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Rear Air suspension has no suspension movement |2.4.D.5| | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Drive shaft which forms part of the suspension coupling gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Front Wheel stud|s| missing |4.2.A.1e| | 1 |
| Offside Rear An item not tested |Manual| | 1 |
| Exhaust emissions likely to be affected by an exhaust leak rear box leaking on joint |8.2.1.1 |b|| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Exhaust has a major leak of exhaust gases centre |7.1.2| | 1 |
| Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Air suspension has no suspension movement |2.4.D.5| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Rear Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Suspension system inoperative |5.3.5 |a|| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Inner Front Anti-roll bar attachment bracket/mounting damaged and its strength is seriously reduced |2.4.G.1| | 1 |
| Offside Front Headlamp levelling device obviously defective |1.7.2| | 1 |
| Nearside Side repeater insecure |1.4.A.2b| | 1 |
| Offside Front Air suspension unit totally deflated |2.4.D.1a| | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Front Upper Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Outer Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front Front suspension has excessive play in a upper suspension ball joint front ball joint |2.5.B.1a| | 1 |
| Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear Air suspension pipe leaking |2.4.D.2| | 1 |
| Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Offside rear brake juddering severely |3.7.A.5b| | 1 |
| Offside Fuel system component insecure |7.2.1| | 1 |
| Nearside Rear rear brake juddering severely |3.7.A.5b| | 1 |
| Offside Rear rear brake juddering severely |3.7.A.5b| | 1 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush rear |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Upper Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Brake hose twisted |3.6.B.4c| | 1 |
| Parking brake lever is impeded in its travel |3.1.6c| | 1 |
| Rear Air suspension unit leaking |2.4.D.2| | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Front Suspension arm worn and seriously weakened |2.4.G.1| | 1 |
| Nearside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint rear arm |2.4.G.2| | 1 |
| Offside Power steering component|s| leaking steering rack end |2.3.3b| | 1 |
| Offside Front Track rod end ball joint worn to the extent there is a serious risk of detachment |2.1.3 |b| |ii|| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Hazard warning switch insecure |1.4.B.1d| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Rear Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
| Rear Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside rear brake juddering severely |3.7.A.5b| | 1 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Front brake caliper securing device missing |3.5.1j| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear Brake pivot has restricted free movement on brake caliper |3.5.1k| | 1 |
| Offside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Rear Fuel hose leaking |7.2.3| | 1 |
| Offside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Horn not working |1.6.2a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Offside Front Air suspension leaking |2.4.D.2| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Air suspension unit leaking |2.4.D.2| | 1 |
| Offside Rear Seat belt flexible stalk deteriorated likely to lead to failure under load |5.2.4a| | 1 |
| Nearside Front Air suspension unit leaking |2.4.D.2| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Outer Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Outer Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt Split and leaking (6.1.7 (g) (ii)) | 1 |
| Nearside Front Upper Suspension arm pin or bush excessively worn forward arm (5.3.4 (a) (i)) | 1 |
| Nearside Front Upper Suspension arm pin or bush excessively worn rearmost arm (5.3.4 (a) (i)) | 1 |
| Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Hydraulic brake calliper leaking |1.1.16 |b| |i|| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Front Exhaust has a major leak of exhaust gases flexi |7.1.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a ball joint link |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush rear arm inner bush |2.4.G.2| | 1 |
| Nearside Front passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Air suspension has no suspension movement |2.4.D.5| | 1 |
| Offside Front Air suspension has no suspension movement |2.4.D.5| | 1 |
| Nearside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |