| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 217 |
| Registration plate lamp issues | 186 |
| Windscreen wiper does not clear the windscreen effectively | 81 |
| Registration plate issues | 67 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 45 |
| Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 35 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 35 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 34 |
| Parking brake: efficiency below requirements |3.7.B.7| | 29 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 28 |
| Rear parking brake recording little or no effort | 27 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 27 |
| Anti-lock braking system warning lamp indicates an ABS fault | 23 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 20 |
| Windscreen has damage | 20 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 19 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 18 |
| Electronic parking brake warning indicates a malfunction |3.1.7| | 17 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 15 |
| Brake pipe excessively corroded | 15 |
| Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 14 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 14 |
| Windscreen washer not working | 13 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 13 |
| Offside Headlamp cleaning device inoperative |1.7.2| | 11 |
| Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 11 |
| Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 11 |
| Front brake disc in such a condition that it is seriously weakened | 11 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 10 |
| Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 10 |
| Nearside Headlamp cleaning device inoperative |1.7.2| | 10 |
| Horn not working |1.6.2a| | 10 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 9 |
| Nearside Rear brake caliper leaking |3.6.A.1| | 9 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 8 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 8 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 8 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 8 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 8 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 8 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 8 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 8 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 7 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 7 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 7 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 7 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 7 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 7 |
| Bootlid cannot be secured in the closed position |6.4.1| | 6 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 6 |
| Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
| Nearside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 6 |
| Electronic parking brake warning indicates a malfunction (1.1.6 (e)) | 5 |
| Headlamp cleaning device inoperative |1.7.2| | 5 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 5 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 5 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 5 |
| Offside Side repeater not working |1.4.A.2c| | 5 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 5 |
| Rear brake binding | 5 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 5 |
| Nearside Stop lamp not working |1.2.1b| | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Nearside Inner Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 5 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 5 |
| Offside Front Upper Suspension arm pin or bush excessively worn rear arm (5.3.4 (a) (i)) | 4 |
| Emissions not tested (8.2.1.2 (d)) | 4 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Front Headlamp cleaning device inoperative |1.7.2| | 4 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 4 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 4 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 4 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 4 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 4 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 4 |
| Electronic parking brake control inoperative (1.1.6 (d)) | 4 |
| Rear brake disc in such a condition that it is seriously weakened | 4 |
| Brakes imbalanced across an axle | 4 |
| Offside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 4 |
| Windscreen wiper blade insecure | 4 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 4 |
| Offside Inner Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Offside Rear Stop lamp not working |1.2.1b| | 4 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 4 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 4 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 4 |
| Nearside Rear Stop lamp not working |1.2.1b| | 4 |
| Offside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 4 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 4 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 4 |
| Offside Front Lower Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 4 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 4 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 4 |